RecallRepo

2021 GMC Savana Recalls

Recalls on record Updated July 2026

The 2021 GMC Savana has 3 NHTSA recall campaigns affecting an estimated 194,822 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 3 complaints with NHTSA, most often about the steering. Last updated July 5, 2026.

Recall campaigns

ELECTRICAL SYSTEM 23V247000 2023-04-06 150,830 affected
Defect

General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the…

Consequence

An overheated electrical circuit increases the risk of a fire.

Remedy

Dealers will properly seal the rear HVAC blower motor circuits at the left side B-pillar, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GMC's number for this recall is N222386050.

ELECTRICAL SYSTEM 21V189000 2021-03-18 10,154 affected
Defect

General Motors, LLC (GM) is recalling certain 2021 Chevrolet Express and GMC Savana vehicles equipped with 6.6L gasoline engines. The positive battery cable terminals may contact a fuse block assembly attachment post and cause an electrical short circuit.

Consequence

A short-circuit can increase the risk of a fire.

Remedy

Owners are advised to park their vehicles outside and away from structures until the repair is complete. GM will notify owners, and dealers will remove a portion of the anti-rotation tab on both positive battery cable terminals near the fuse block assembly attachments, free of charge. If too much of the tab had…

TIRES 21V115000 2021-02-25 33,838 affected
Defect

General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC Savana, 2019-2020 Chevrolet Blazer, Silverado 1500, GMC Acadia, Sierra 1500, and certain Continental tires sold to the…

Consequence

Over cured tires may develop a break in the sidewall resulting in sudden air loss or a belt edge separation which could lead to a tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.

Remedy

GM will notify owners, and dealers will inspect the tires, replacing them as necessary, free of charge. The recall began March 22, 2021. Owners may contact GMC customer service at 1-888-988-7267, Buick customer service at 1-866-608-8080, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at…

Complaints by component

STEERING
2
ENGINE
1
Total complaints3

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Power steering lines leaking and hydroboost. Third vehicle in fleet with 64000 miles and same issue.”

STEERING · reported 2024-06-20

“The contact owns a 2021 gmc savana. The contact stated while driving at undisclosed speeds, the steering wheel was stiff. The power steering fluid was leaking. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the pcm, power…”

STEERING · reported 2024-03-11

“The contact owns a 2021 gmc savana. The contact stated while driving at undisclosed speeds, the steering wheel was stiff. The power steering fluid was leaking. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the pcm, power…”

ENGINE · reported 2024-03-11

Defect investigations

Investigation PE23016 Opened 2023-09-27 · closed 2025-01-10

6L90 Transmission Failure

The Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) after receiving one Vehicle Owner Questionnaire (VOQ) complaint related to four school buses built on General Motors (GM) van chassis. The VOQ alleged transmission failure resulting in a loss of all forward gear. In ODI's…

Investigation PE23016 Opened 2023-09-27 · closed 2025-01-10

6L90 Transmission Failure

The Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) after receiving one Vehicle Owner Questionnaire (VOQ) complaint related to four school buses built on General Motors (GM) van chassis. The VOQ alleged transmission failure resulting in a loss of all forward gear. In ODI's…

Investigation PE23016 Opened 2023-09-27 · closed 2025-01-10

6L90 Transmission Failure

The Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE) after receiving one Vehicle Owner Questionnaire (VOQ) complaint related to four school buses built on General Motors (GM) van chassis. The VOQ alleged transmission failure resulting in a loss of all forward gear. In ODI's…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2021 GMC Savana as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.