The 2000 Gem Nev has 1 NHTSA recall campaign affecting an estimated 27,350 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 2 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.
ON CERTAIN 2 AND 4 PASSENGER, SHORT AND LONG BED LOW SPEED VEHICLES, THE 12 VOLT OUTPUT FROM THE AUXILIARY CARD CIRCUIT BOARD (A DC VOLTAGE TO DC VOLTAGE CONVERTER) MAY BECOME INOPERATIVE AND RESULT IN LOSS OF HEADLAMP, TAIL LAMP AND TURN SIGNAL LAMP FUNCTIONS.
Consequence
A LOSS OF HEADLAMPS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH. IF THERE IS A LOSS OF TAIL LAMP OR TURN SIGNAL LAMP FUNCTION, A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED OR THAT THE VEHICLE IN FRONT IS TURNING, A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy
DEALERS WILL REPLACE THE AUXILIARY CARDS, INSTALL A SPLASH/SPRAY PROTECTION, AND ADJUST THE DASH SEAL FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS MAY CONTACT GLOBAL ELECTRIC AT 888-871-4367.
Complaints by component
ELECTRICAL SYSTEM
2
Total complaints2
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Tl*the contact owns a 2000 gem nev. The contact stated that there is a safety recall # 06v222000 on his cart's electrical system. He has scheduled two appointments for the recall repair and both times no one showed up. The contact stated that the electric components on his cart failed in may of…”
“Gem e825/4 passenger cart with a safety recall. Customer stated the cart was inspected and was supposed to be repaired. The dealer told him they could not repair the cart until he bought a new battery charger. *kb the consumer stated that the dealer informed him that they found that the new…”
Defect investigations
InvestigationDP22005 Opened 2023-01-27 · closed 2023-08-07
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2000 Gem Nev as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.