The 2000 Freightliner Fs-65 has 6 NHTSA recall campaigns affecting an estimated 79,952 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 12 complaints with NHTSA, most often about the fuel system, diesel. Last updated July 5, 2026.
CERTAIN 1998-2003 MY FREIGHTLINER FS-65 SCHOOL BUS CHASSIS AND MB-45, MB-55, AND XB SHUTTLE BUS CHASSIS, AND THOMAS BUILT BUS: MVP-ER AND MVP-EF SCHOOL BUS AND NON-SCHOOL BUS MODELS EQUIPPED WITH CUMMINS ISB DIESEL ENGINES AND EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS. THE FUEL PUMP COULD FAIL TO…
Consequence
SHOULD THE ENGINE STALL WHILE THE VEHICLE IS IN USE, A POSSIBLE VEHICLE CRASH COULD OCCUR.
Remedy
CUMMINS WILL NOTIFY THE CUSTOMERS OF FREIGHTLINER AND THOMAS BUILT AND REPLACE THE FUEL LIFT PUMP FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS.
SERVICE BRAKES, HYDRAULIC04V3430002004-07-123,200 affected
Defect
ON CERTAIN SCHOOL BUSES CHASSIS EQUIPPED WITH CATERPILLAR ENGINES AND HYDRAULIC BRAKES. A BRAIDED GROUND STRAP FOR THE STARTER MAY RUB ON A STEEL CHASSIS BRAKE LINE POTENTIALLY CAUSING A FLUID LEAK.
Consequence
A BRAKE FLUID LEAK CAN REDUCE BRAKING EFFECTIVENESS AND INCREASE THE STOPPING DISTANCE, WHICH COULD RESULT IN A CRASH.
Remedy
DEALERS WILL INSPECT THE BRAKE LINE AND REPLACE IT, IF NECESSARY. THE BRAIDED GROUND STRAP WILL BE REPLACED WITH AN INSULATED CABLE. THE RECALL BEGAN ON AUGUST 10, 2004. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
SERVICE BRAKES, HYDRAULIC02V0840002002-04-0216,000 affected
Defect
ON CERTAIN SCHOOL BUSES, THE BRAKE HOSES FROM THE CHASSIS TO FRONT BRAKE CHAMBERS COULD DEVELOP LEAKS DUE TO THE HOSE ROUTING THAT COULD OVERSTRESS THE HOSE DURING SHARP TURNS.
Consequence
THE VEHICLE COULD HAVE REDUCED BRAKING CAPACITY, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT FOR IMPROPER ROUTING. IF IMPROPER ROUTING IS FOUND, DEALERS WILL REPLACE AND CORRECT THE HOSE ROUTING. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME…
VEHICLE DESCRIPTION: BUS CHASSIS VEHICLES. AN ELECTRICAL PASS-THROUGH CONNECTOR MAY NOT FIT IN THE FIREWALL MOUNTING HOLE CORRECTLY, RESULTING IN THE CONNECTOR DISLODGING AND AN ELECTRICAL TERMINAL CONTACTING THE FIREWALL.
Consequence
THIS CAN CAUSE AN ELECTRICAL SHORT AND POTENTIAL FIRE.
Remedy
DEALERS WILL INSPECT VEHICLES FOR PROPER MOUNTING OF THE ELECTRICAL PASS THROUGH AND CORRECT IF NECESSARY. OWNER NOTIFICATION BEGAN OCTOBER 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT…
POWER TRAIN00V2290012000-08-17594 affected
Defect
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS, SHUTTLE BUSES, TRANSIT BUSES AND STEP VANS EQUIPPED WITH ALLISON 1000 OR 2400 SERIES TRANSMISSIONS. THESE TRANSMISSIONS CAN EXPERIENCE PARK PAWL TO REAR COVER INTERFERENCE DUE TO AN OUT OF FLATNESS CONDITION.
Consequence
THIS COULD CAUSE NON-ENGAGEMENT OF THE PARK PAWL WHEN THE TRANSMISSION SHIFT SELECTOR IS MOVED TO THE PARK POSITION, RESULTING IN UNINTENDED VEHICLE MOVEMENT AND A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy
ALLISON TRANSMISSION IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REMOVE THE TRANSMISSION FROM THE VEHICLE, REPLACE THE PARK PAWL, AND REINSTALL THE TRANSMISSION IN THE VEHICLE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN…
SERVICE BRAKES, AIR00V2320022000-08-0735,405 affected
Defect
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END…
Consequence
THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
Remedy
DEALERS WILL REPLACE THE ABS ECU.
Complaints by component
FUEL SYSTEM, DIESEL
12
Total complaints12
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Dt: the contact owned a 2000 and 2001 freightliners. Contact was unable to get the recall repair work on fuel system done because the manufacturer will not pay the dealership enough to do the repair work. Had 20 of these vehicles, 2000-2001 year models. Could do do the repairs themselves, but they…”
“Dt: the contact owned a 2000 freightliner. Contact was unable to get the recall repair work on fuel system done because the manufacturee will not pay the dealership enough to do the repair work. Had 20 of these vehicles, 2000-2001 year models. Could do the repairs themselves, but they could not do…”
“Dt: the contact owned a 2000 freightliner. Contact was unable to get the recall repair work in fuel system done because the manufacturer will not pay the dealership enough to do the repair work. Had 20 of these vehicles, 2000-2001 year models. Could do the repairs themselves, but they could not do…”
“Dt: the contact owned a 2000 freightliner. Contact was unable to get the recall repair work on fuel system done because the manufacturer will not pay the dealership enough to do the repair work. Had 20 of these vehicles, 2000-2001 year models. Could do the repairs themselves, but they could not do…”
“Dt: the contact owned a 2000 freightliner. Contact unable to get the recall repair work on fuel system done because the manufacturer will not pay the dealership enough to do the repair work. Had 20 of these vehicles, 2000-2001 year models. Could do the repairs themselves, but they could not do…”
“Dt: the contact owned a 2000 freightliner. Contact was unable to get the recall repair work on fuel system done because the manufacturer will not pay the dealership enough to do the repair work. Had 20 of these vehicles, 2000-2001 year models. Could do the repairs themselves, but they could not do…”
“Dt: the contact owned a 2000 freightliner. Contact was unable to get the recall repair work on fuel system done because the manufacturer will not pay the dealership enough to do the repair work. Had 20 of these vehicles, 2000-2001 year models. Could do the repairs themselves, but they could not do…”
“Dt: the contact owned a 2000 freightliner. Contact was unable to get the recall repair work on fuel system done because the manufacturer will not pay the dealership enough to do the repair work. Ha 20 of these vehicles ,2000-2001 year models. Could do the repairs themselves, but they could not do…”
Defect investigations
InvestigationPE02024 Opened 2002-02-22 · closed 2002-03-25
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2000 Freightliner Fs-65 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.