The 2009 Ford F-650 Sd has 3 NHTSA recall campaigns affecting an estimated 6,322 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 1 complaint with NHTSA, most often about the service brakes. Last updated July 5, 2026.
Recall campaigns
ENGINE AND ENGINE COOLING10V3980002010-09-093,469 affected
Defect
FORD IS RECALLING CERTAIN MODEL YEAR 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH CATERPILLAR C7 ENGINE. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.
Consequence
A FUEL LEAK, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A VEHICLE FIRE.
Remedy
FORD IS WORKING WITH CATERPILLAR TO NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED CATERPILLAR DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 8, 2010. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR FORD AT 1-866-436-7332.
EXTERIOR LIGHTING09V4760002009-12-1542 affected
Defect
FORD IS RECALLING MODEL YEARS 2009 F-650 AND F-750 TRUCKS. THE CHASSIS WIRE HARNESS MAY HAVE BEEN ASSEMBLED WITHOUT A CONNECTOR SEAL IF THIS SEAL IS MISSING, THE CONNECTOR TERMINALS MAY CORRODE AFFECTING THE PROPER ILLUMINATION OF THE VEHICLE'S REAR BRAKE LAMPS, TAIL LAMPS, TURN SIGNAL LAMPS OR TRAILER LAMPS (IF…
Consequence
INOPERATIVE LAMPS MAY INCREASE THE RISK OF A CRASH.
Remedy
DEALERS WILL INSPECT THE CONNECTOR AND REPAIR THE MAIN AND REAR CHASSIS WIRE HARNESS IF NECESSARY. A MISSING SEAL WILL BE REPLACED AND ELECTRICAL GREASE APPLIED TO PREVENT FUTURE CORROSION. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2009. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR THROUGH THE INTERNET AT…
ENGINE AND ENGINE COOLING08V4280002008-08-252,811 affected
Defect
FORD IS RECALLING 2,811 MY 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.
Consequence
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy
FORD IS WORKING WITH CATERPILLAR (PLEASE SEE 08E042). CATERPILLAR WILL REPLACE THE FUEL PUMP PLUG FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986, OR FORD AT 1-800-343-5338 (FLEET OWNERS) OR 1-866-906-9811 (MOTOR HOME OWNERS).
Complaints by component
SERVICE BRAKES
1
Total complaints1
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Tl* the contact owns a 2009 ford f-650 sd. The contact stated that while driving at approximately 40 mph, the brake pedal was depressed but the brakes failed to respond. The contact had to make a sharp left turn to avoid crashing into a vehicle. The emergency brake was activated and shifted the…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2009 Ford F-650 Sd as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.