The 2005 Fleetwood Tioga Sl has 2 NHTSA recall campaigns affecting an estimated 332 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 3 complaints with NHTSA, most often about the power train. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT08V2320002008-05-22135 affected
Defect
FLEETWOOD IS RECALLING 135 MY 2004-2006 JAMBOREE GT AND TIOGA SL 29S MODEL MOTOR HOMES. THE BLACK IRON PROPANE PLUMBING, LOCATED UNDER THE MOTOR HOME, MAY COME INTO CONTACT WITH CHASSIS COMPONENTS AND, UNDER CERTAIN CONDITIONS, BECOME PINCHED OR CRUSHED.
Consequence
THIS COULD LEAD TO A PROPANE GAS LEAK AND THE POTENTIAL FOR AN EXPLOSION AND/OR FIRE.
Remedy
DEALERS WILL INSPECT AND RELOCATE THE BLACK IRON PROPANE PIPE WITH A KIT THAT PROVIDES THE COMPONENTS TO MOVE THE LINE TO THE SIDE OF THE CHASSIS FRAME RAIL. DEALERS WILL PERFORM THIS REMEDY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 20, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
EQUIPMENT04V4190002004-08-27197 affected
Defect
ON CERTAIN CLASS C MOTOR HOMES, THE RANGE TOP LIQUID PROPANE GAS (LPG) CONNECTION LINE IS A FLEXIBLE HOSE CONNECTOR. THIS HOSE IS ROUTED IN CLOSE PROXIMITY TO A BURNER AND MAY MELT WHEN EXPOSED TO HIGH HEAT FOR A PERIOD OF TIME.
Consequence
IF MELTING OCCURS THERE IS A POTENTIAL FOR A FIRE.
Remedy
DEALERS WILL REPLACE THE RUBBER LPG HOSE CONNECTION IN THE RANGE TOP WITH A COPPER LPG CONNECTION. THE RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT FEETWOOD AT 1-800-322-8216.
Complaints by component
POWER TRAIN:DRIVELINE:DRIVESHAFT
1
SUSPENSION:FRONT
1
1crashes1fires
SUSPENSION:MULTIPLE AXLE
1
Total complaints3
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“We purchased a brand new 26' fleetwood terra motorhome. On the first trip it was a bit hard to manage at speeds above 55 mph. I blamed inexperience and weather conditions, although other rigs were passing me like I was standing still. Four hundred miles traveled. At 53 mph exiting the freeway at a…”
“Purchased 2005 rv in ga nov. 2004. While traveling from ga to tx noticed heavy vibration under floor of kitchen area of vehicle. Worse by the time we reached tx. Found out it was the drive shaft. Had it repaired. Drove to las cruces, nm. Vibration still there. Had another drive shaft installed.…”
“This pretains to camping trailers. Thor manufacturer creates dutchmen 5th wheel trailers. My girlfreind and I purchased a new dutchmen/victory lane 35ft 5th wheel toy hauler and the axles are mounted off center. This makes the tires face at an angle and the trailer does not track correctly. This…”
Defect investigations
InvestigationPE06005 Opened 2006-01-20 · closed 2006-05-02
INADVERTENT SLIDE-OUT EXTENSION MOVEMENT
THIS INVESTIGATION WAS OPENED BASED ON ODI'S RECEIPT OF A CONGRESSIONAL LETTER ON BEHALF OF A CONSTITUENT.THE CONSTITUENT REPORTED INCIDENTS WHERE THE SLIDE OUT ROOM OF HIS MOTOR HOME WOULD INADVERTENTLY MOVE (EXTEND) DURING HIGHWAY USE.ODI WAS CONCERNED THAT A FULLY EXTENDED SLIDE OUT WOULD DEGRADE THE VEHICLE'S…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2005 Fleetwood Tioga Sl as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.