The 2000 Fleetwood Flair has 3 NHTSA recall campaigns affecting an estimated 239,167 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 11 complaints with NHTSA, most often about the equipment. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT07V1200002007-03-19167,096 affected
Defect
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence
RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy
FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST…
EQUIPMENT03V4520002003-11-0460,877 affected
Defect
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Consequence
AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy
SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR…
SERVICE BRAKES, HYDRAULIC03V0660002003-03-0411,194 affected
Defect
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence
IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy
DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-445-3307.
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Headlight glass shattered for no reason after owning for one week. Note there is already a recall on this glass but manufacturer claims that this unit was manufactured after the window of the recall so it could not have been affected. But I have confirmed that this unit does have the defective…”
“Tl*the contact owns a 2000 fleetwood flair rv. The contact stated that he was unable to have the dometic refrigerator (model # 2852) repaired. The authorized dealers recommended by the manufacturer were not willing to repair the refrigerator, stating that dometic had not allocated enough money for…”
“Fleetwood flair motorhome 2000, faulty brakes. *bf the consumer stated the rear brake calipers locked up which caused the brake pads to crystallize. The shower was broken, the dealer installed a new shower hose, the consumer complained of a noise in the front end during a hard right/left turn, the…”
“Fleetwood flair motorhome 2000, faulty brakes. *bf the consumer stated the rear brake calipers locked up which caused the brake pads to crystallize. The shower was broken, the dealer installed a new shower hose, the consumer complained of a noise in the front end during a hard right/left turn, the…”
“Fleetwood flair motorhome 2000, faulty brakes. *bf the consumer stated the rear brake calipers locked up which caused the brake pads to crystallize. The shower was broken, the dealer installed a new shower hose, the consumer complained of a noise in the front end during a hard right/left turn, the…”
“Hydraulic jacks are leaking, one of the four supplied with vehicle had to be replaced.*ak”
“While driving 60 mph, consumer heard a loud noise at front of vehicle, dealer determined body welds at front compartment were breaking. Vehicle has been taken to dealer twice for this problem.*ak on the first occasion, 4 pieces of angle iron 1-1/2 ft. Long and bolted to reinforce the heat shield…”
“While driving 60 mph, consumer heard a loud noise at front of vehicle, dealer determined body welds at front compartment were breaking. Vehicle has been taken to dealer twice for this problem.*ak on the first occasion, 4 pieces of angle iron 1-1/2 ft. Long and bolted to reinforce the heat shield…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2000 Fleetwood Flair as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.