The 2006 Fleetwood Expedition has 4 NHTSA recall campaigns affecting an estimated 77,554 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 8 complaints with NHTSA, most often about the visibility. Last updated July 5, 2026.
FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.
Consequence
THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.
Remedy
DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
EQUIPMENT08V3200002008-07-1570,101 affected
Defect
FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND…
Consequence
IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.
Remedy
FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN…
EQUIPMENT06V0550002006-02-231,236 affected
Defect
ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC ENTRY STEP BUILT WITH A CONTROL UNIT MANUFACTURED BY AMERICAN TECHNOLOGIES, MAY DEVELOP AN ELECTRICAL SHORT DURING COLD WEATHER, ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE.
Consequence
THIS WILL MAKE THE STEP INOPERABLE AND POSSIBLY RESULT IN A RISK OF PERSONAL INJURY, VEHICLE OR OTHER PROPERTY DAMAGE.
Remedy
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE ALL AMERICAN TECHNOLOGIES CONTROLS ASSOCIATED WITH THE KWIKEE BRAND ELECTRIC ENTRY STEP FREE OF CHARGE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
EQUIPMENT05V3330002005-07-272,435 affected
Defect
CERTAIN DIESEL CLASS A MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE MANUFACTURERS' TOW HITCH RECEIVER INFORMATION LABEL WAS PRINTED WITH THE INCORRECT WEIGHT CARRYING CAPACITY VALUE AND THE INCORRECT TONGUE WEIGHT VALUE.
Consequence
THE WEIGHT LABEL ON THE HITCH RECEIVER PROVIDES THE MAXIMUM TRAILER WEIGHT RATING AND THE MAXIMUM TONGUE WEIGHT RATING. IT IS IMPORTANT THAT THESE RATINGS NOT BE EXCEEDED. FAILURE TO COMPLY COULD RESULT IN DAMAGE TO THE MOTOR HOME FRAME, BODY, OR HITCH RECEIVER AND COULD CAUSE UNSTABLE DRIVING AND HANDLING…
Remedy
FLEETWOOD WILL MAIL OWNERS THE CORRECT TOW HITCH RECEIVER WEIGHT INFORMATION LABEL. IF OWNERS DO NOT FEEL COMFORTABLE INSTALLING THE LABEL, DEALERS WILL INSTALL THE LABEL FOR THEM. THE RECALL BEGAN AUGUST 4, 2005. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
Complaints by component
VISIBILITY
2
VISIBILITY/WIPER
2
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
1
1fires
STRUCTURE
1
VISIBILITY:GLASS, SIDE/REAR
1
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
1
Total complaints8
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The windows on the motorcoach are double pane and or foggy on the inside. It is a definite safety hazard, especially the windows on the driver and passenger side. It is difficult to see the rearview mirrors with the foggy windows.”
“Tl* the contact owns a 2006 fleetwood expedition. While parked, the vehicle caught fire underneath the dashboard. The contact was able to extinguish the fire. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 53,700.”
“Tl* the contact owns a 2006 fleetwood expedition. The contact stated that the seal on the passenger and driver's side windows were fractured and caused the windows to constantly become foggy. The vehicle was not taken to the dealer for inspection. The vehicle was not repaired. The manufacturer was…”
“Thermal pane windows on both the drivers and passenger sides of my recreational vehicle are fogging between the glass panes restricting vision especially at night. A search on the internet revealed that this is a common problem. *tr”
“Tl*the contact owns a 2006 fleetwood expedition rv. In warm weather, all of the windows become foggy and the driver's side window is constantly grayish in color. She took the vehicle in for a diagnostic and discovered that all of the windows had defective seals. The dealer stated that the windows…”
“Tl*the contact owns a 2006 fleetwood expedition. The contact started the ignition in the vehicle and noticed that a large portion of the front driver's side window was fogged. The condensation blocked visibility in or out of the window. The moisture could not be removed easily. The authorized…”
“Tl*the contact owns a 2006 fleetwood expedition. The contact started the ignition in the vehicle and noticed that a large portion of the front driver's side window was fogged. The condensation blocked visibility in or out of the window. The moisture could not be removed easily. The authorized…”
“The passenger side external mirror on the rv will not stay in place. We have now visited at least 6 authorized dealers for this problem to be resolved - one even claimed to have replaced the mirror unit. The mirror isn't able to remain in a fixed place (especially when going over periods of…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2006 Fleetwood Expedition as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.