RecallRepo

2007 Fleetwood Discovery Recalls

Recalls on record Updated July 2026

The 2007 Fleetwood Discovery has 3 NHTSA recall campaigns affecting an estimated 91,883 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 4 complaints with NHTSA, most often about the electrical system. Last updated July 5, 2026.

Recall campaigns

ELECTRICAL SYSTEM 09V056000 2009-02-18 3,782 affected
Defect

FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.

Consequence

THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.

Remedy

DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

EQUIPMENT 08V320000 2008-07-15 70,101 affected
Defect

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND…

Consequence

IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Remedy

FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN…

STEERING 07V306000 2007-07-18 18,000 affected
Defect

FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE…

Consequence

INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.

Remedy

THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

Complaints by component

ELECTRICAL SYSTEM
1
ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
1
EQUIPMENT:RECREATIONAL VEHICLE/TRAILER
1
VISIBILITY/WIPER
1
Total complaints4

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Various windows in the coach are cloudy and can not be cleaned , impairing vision. I have tried to clean them but it appears to be in between the window panes. I was pulling off of the freeway off ramp and when I went to turn on to the main road, I was nearly t-boned by an 18 wheeler. The…”

VISIBILITY/WIPER · reported 2016-10-03

“We have a 2007 fleetwood discovery. It has had some electrical problems that were repaired while it was still under warranty. We had not had any problems with it since nov 2008. In june while camping my husband went to open an outside bin and got shocked. If you touch the outside of the rv any…”

ELECTRICAL SYSTEM · reported 2009-06-20

“Notice by fleetwood about the battery cable recall. Tried to get it fixed at rnr rv in liberty lake washington. They did not have parts, but ordered the parts. We are full time rvers and were unable to take the motor home back. They gave us the parts. Tried to get the problem fixed at another rv…”

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES · reported 2009-06-10

“Dt*: the contact stated when the couch was converted into a bed; there was no room to walk past the bed or exit in case of an emergency. The sales dealer was unable to make changes due to the seatbelt requirements for the coach. The manufacturer was notified. Manufacturer: fleetwood. Model:…”

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER · reported 2006-12-08
Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2007 Fleetwood Discovery as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.