The 2000 Fleetwood Discovery has 2 NHTSA recall campaigns affecting an estimated 172,063 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 10 complaints with NHTSA, most often about the structure. Last updated July 5, 2026.
Recall campaigns
EQUIPMENT07V1200002007-03-19167,096 affected
Defect
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence
RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy
FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST…
STEERING00V2040002000-07-274,967 affected
Defect
VEHICLE DESCRIPTION: MOTOR HOMES. THE POWER STEERING GEAR BOX HYDRAULIC LINES ARE ROUTED TOO CLOSE TO A SHARP EDGE. THIS CAN CAUSE THE LINES TO RUPTURE AND RESULT IN A HYDRAULIC FLUID LEAK.
Consequence
THIS FLUID LEAKAGE CAN CAUSE LOSS OF THE POWER STEERING ASSIST FEATURE.
Remedy
DEALERS WILL INSPECT, REPLACE OR REPAIR DAMAGED HOSES AS NECESSARY, AND RELOCATE THE AFFECTED HYDRAULIC LINES.
Complaints by component
STRUCTURE:BODY:DOOR
2
TIRES:SIDEWALL
2
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
1
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
1
FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP
1
STRUCTURE:FRAME AND MEMBERS
1
TIRES
1
UNKNOWN OR OTHER
1
Total complaints10
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Cummins 5.9 isb lift pump failure at 40,000 miles caused engine to over heat and stall. A vehicle crash could have occurred. Similar to nhtsa #05e054000. *jb”
“Dt: contact states while driving the front passenger door whistles, water leaks in, the door came opened. The door has been replaced once.”
“Michlin 235-80-22.5 tire blew out (right inner dual side wall).traveling at 60 mph. Just had motorhome weighed at each cornerat rally in texas 2 days before blowout and it was within weight and tire pressure limits. 2000 discovery (36,000) miles caused $3100.00 damage to body. 2 weeks later while…”
“While driving, the vehicle suffered a blow out on one of the tires. The blowout caused a 9 inch tear in the sidewall. Michelin has not responded to consuemrs request for a prorated adjustment of the replacement. The tire is a michelin xrl 235/80r 22.5 *jg *dt”
“Left rear outside blew out. Supposdly caused by a "screw" approx 1 1/4 inch. Tore cabling apart without cuasing a leak. Posssible but not probable. A tire so large to cuase to blow outby something so small. *ak (dot number: b6bj bvjx tiresize: 735/80/225)”
“Body mount separated from frame. Manufacturer has been notified. Please provide additional information.*ak”
“Lower attachment appliances and cabinets are separating from wall. Dealer notified, and put on nail adhesive for repairs. Asking for nhtsa help in this matter. Please provide us with any further details on this matter. *ak”
“Consumer purchased the motorhome with the cummins 1sb300 engine, however the engine has experienced problems, the new units were installed with faulty oil pressure sensors which has to be replaced, then the fuel line broke leaking fuel due to a defect which was known by the manufacturer. Consumer…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2000 Fleetwood Discovery as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.