The 1999 Dodge Caravan has 5 NHTSA recall campaigns affecting an estimated 2,826,972 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 745 complaints with NHTSA, most often about the air bags. Last updated July 5, 2026.
Recall campaigns
AIR BAGS04V4800002004-10-06955,344 affected
Defect
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
Consequence
THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy
DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL COVERED VEHICLES WITH 70,000 MILES OR LESS. FOR THOSE VEHICLES WITH MORE THAN 70,000 MILES, DAIMLERCHRYSLER WILL OFFER AN EXTENDED LIFETIME WARRANTY UNDER WHICH IT WILL REPLACE THE CLOCKSPRING AT NO CHARGE IF IT FAILS. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS…
SEAT BELTS02V0760002002-03-08545,311 affected
Defect
ON CERTAIN MINIVANS, SOME TRIM MATERIAL CAN LOOSEN AND DROP INTO THE REAR OUTBOARD SEAT BELT ASSEMBLY, CAUSING THE SEAT BELT TO BECOME INOPERATIVE.
Consequence
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy
DEALERS WILL REPLACE THE TRIM WITH FOAM BLOCKERS AND INSPECT AND REPLACE ALL 3RD ROW SEAT BELT ASSEMBLIES. OWNER NOTIFICATION BEGAN JUNE 3, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT…
SEAT BELTS01V1190002001-04-11161,682 affected
Defect
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence
IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy
DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence
FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy
DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE…
VEHICLE DESCRIPTION: MINI VANS BUILT FOR FLEET SALES ONLY. THE HEADLAMP MODULE DOES NOT IDENTIFY THE PARK LAMP AS "DRL" AS REQUIREMENT OF FMVSS 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence
THESE VEHICLES DO NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108.
Remedy
ALL FLEET OWNERS/OPERATORS WILL BE MAILED NON-REMOVABLE DECALS WITH THE REQUIRED "DRL" LETTERS.
Complaints by component
AIR BAGS
81
10crashes7injuries
POWER TRAIN:AUTOMATIC TRANSMISSION
74
2crashes2injuries
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
34
2crashes
ELECTRICAL SYSTEM:HORN
33
2crashes
AIR BAGS:FRONTAL
30
13crashes14injuries
ENGINE AND ENGINE COOLING:ENGINE
27
1fires
ENGINE AND ENGINE COOLING
21
2fires
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
20
8fires2injuries
VEHICLE SPEED CONTROL
18
3crashes
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
16
3crashes1injuries
Total complaints745
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The contact owns a 1999 dodge caravan. The contact stated while driving 30 mph, the vehicle failed to function as needed. There were no warning lights illuminated. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the timing belt needed to be replaced.…”
“Tl* the contact owns a 1999 dodge caravan. The contact stated that while driving at various speeds, the steering wheel ceased without warning. The vehicle was towed to the contact's residence. An independent mechanic diagnosed the vehicle and informed the contact that the serpentine belt was…”
“Tl* the contact owns a 1999 dodge caravan equipped with goodyear tires, tire line: all season assurance, tire size: 215/65/r15, dot number: md5ujv1r2317. The contact stated while driving, the vehicle pull to the left and then to the right. The contact stated the front passenger side tire was…”
“Tl* the contact owns a 1999 dodge caravan. The contact stated that the air bag warning light was constantly illuminated on the instrument panel. The vehicle was not diagnosed nor repaired. The vin was not included in nhtsa campaign number: 04v480000 (air bags). The manufacturer was not notified of…”
“"takata recall" thge serpintine belt keeps breaking or comming off while driving normally. I ve had it repkaced numberous times. They told me it was the pulley, I changed that. And the belt has come off again!”
“Tl* the contact owns a 1999 dodge caravan. The contact stated that the fuel gauge failed to work properly. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the issue. The failure mileage was 194,875.”
“Tl* the contact owns a 1999 dodge caravan. While driving at approximately 60 mph, the engine stalled and the check engine warning indicator illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the fuel pump failed and needed to be replaced. The vehicle was…”
“Tl* the contact owns a 1999 dodge caravan. While driving at approximately 60 mph, the engine stalled and the check engine warning indicator illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the fuel pump failed and needed to be replaced. The vehicle was…”
Defect investigations
InvestigationEA01007 Opened 2001-02-21 · closed 2002-11-22
AIR BAG CLOCKSPRING
There is no summary currently available
InvestigationEA04013 Opened 2004-06-04 · closed 2005-05-25
DRIVER AIR BAG CLOCKSPRING FAILURE
THE DRIVER AIR BAG CLOCKSPRING CAN DEVELOP AN OPEN-CIRCUIT CONDITION RESULTING IN NONFUNCTIONAL DRIVER-SIDE FRONTAL AIR BAG, HORN, CRUISE CONTROL (IF EQUIPPED), AND/OR STEERING WHEEL RADIO CONTROL (IF EQUIPPED).IN ITS OCTOBER 5, 2004 LETTER TO NHTSA, DAIMLERCHRYSLER STATED THAT IT WILL CONDUCT A SAFETY RECALL AND…
InvestigationEA99013 Opened 1999-06-11 · closed 2001-08-10
POST COLLISION FUEL SYSTEM
InvestigationPE99010 Opened 1999-02-03 · closed 1999-06-11
POST-COLLISION FUEL SYSTEM INTEGRITY
There is no summary currently available
InvestigationRQ00008 Opened 2000-03-09 · closed 2002-03-18
DC MINIVAN FUEL INJECTOR RAIL LEAK
There is no summary currently available
InvestigationRQ04001 Opened 2004-01-28 · closed 2004-06-04
DRIVER AIR BAG CLOCKSPRING FAILURE
COMPLAINTS REPORT AIR BAG WARNING LIGHT ILLUMINATES, AND THIS MAY BE ACCOMPANIED WITH A NON-FUNCTIONING HORN AND/OR CRUISE CONTROL (IF EQUIPPED).THIS IS INDICATIVE OF AN OPEN-CIRCUIT CLOCKSPRING FAILURE (RESULTS IN NON-FUNCTIONING DRIVER'S AIR BAG), SIMILAR TO THE FAILURE CONDITION THAT WAS THE SUBJECT OF…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1999 Dodge Caravan as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.