The 2005 Country Coach Inspire has 4 NHTSA recall campaigns affecting an estimated 2,307 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 8 complaints with NHTSA, most often about the steering. Last updated July 5, 2026.
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUE AND 45 DEGREES AS SPECIFIED IN THE…
Consequence
THE INADEQUACY OF THE FRONT AND REAR SIDE MARKER LIGHTS COULD AFFECT VISIBILITY OF THE MOTOR HOME DURING HOURS OF DARKNESS THAT COULD POTENTIALLY RESULT IN A MOTOR VEHICLE CRASH.
Remedy
DEALERS WILL REPLACE THE MARKER LIGHTS ON THE SIDE AS CLOSE AS REASONABLE TO THE FRONT AND REAR CORNERS AND WIRED INTO THE PARK LIGHT SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 19, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.
EQUIPMENT04V4630002004-09-21349 affected
Defect
ON CERTAIN MOTOR HOMES, LIQUID PROPANE (LP) GAS COOK TOPS WERE INSTALLED USING A FLEXIBLE RUBBER HOSE THAT COULD BURN OR MELT.
Consequence
IF UNDETECTED, THE HOSE COULD BURN THROUGH AND RESULT IN A LP GAS FIRE.
Remedy
DEALERS WILL REPLACE THE COOK TOP RUBBER HOSE WITH COPPER TUBING. THE RECALL BEGAN ON NOVEMBER 8, 2004. CUSTOMERS CAN CONTACT COUNTRY COACH AT 1-541-998-3720.
ELECTRICAL SYSTEM04V4640002004-09-21380 affected
Defect
ON CERTAIN MOTOR HOMES, A CIRCUIT BREAKER IN THE CLEARANCE LIGHT CIRCUIT DOES NOT PROTECT THE CIRCUIT FROM A TOO HIGH AMPERAGE DRAW CAUSED BY A TOWED PASSENGER VEHICLE.
Consequence
THE CIRCUIT BREAKER CAN OVERHEAT THE WIRE AND INSULATION TO A POINT WHICH COULD CAUSE A FIRE.
Remedy
DEALERS WILL REPLACE THE DEFECTIVE CIRCUIT BREAKERS. THE RECALL BEGAN ON NOVEMBER 8, 2004. CUSTOMERS CAN CONTACT COUNTRY COACH AT 1-541-998-3720.
STEERING04V2590002004-06-07527 affected
Defect
ON CERTAIN MOTOR HOMES EQUIPPED WITH AN INDEPENDENT FRONT SUSPENSION (IFS) GEN II BUILT BY HOLLAND USA, THE GEAR PLATE SUPPORT GUSSETS WERE REMOVED. THIS CAN ALLOW THE PLATE TO FLEX DURING A STATIC STEER CONDITION.
Consequence
THE FLEXING MAY RESULT IN STRESS CRACKING WHICH COULD POTENTIALLY CAUSE A LOSS OF VEHICLE STEERING CONTROL WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy
HOLLAND USA IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. A BOLT-ON STRENGTHENING OF THE STEERING GEAR PLATE WITH U-BOLTS CONNECTING THE CROSS MEMBER TO EACH SIDE OF THE GEAR PLATE AT THE REAR PLUS A TUBE SUPPORT IN THE FRONT WITH J-BOLTS TO THE GEAR PLATE WILL BE INSTALLED. OWNERS SHOULD…
Complaints by component
STEERING
3
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
2
ENGINE AND ENGINE COOLING
1
EXTERIOR LIGHTING
1
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
1
Total complaints8
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“2005 country coach / inspire- sudden loss of steering and control of motor home due to complete failure of power take off and pumps. The gears have no lubrication and completely stripped resulting in a sudden and complete failure of steering capability this stranded us in the middle of i10 west…”
“Tl*the contact owns a 2005 country coach inspire rv. The contact stated that the pto was deteriorated because it was dry lubricated. He has not taken the vehicle to the dealer, but speculated that if the component was wet lubricated, the failure would be corrected. The vehicle has not been…”
“While traveling to alaska in our 2005 country coach inspire we had a transmission oil cooler failure which caused the engine coolant to drain into the transmission and causing it to fail. We had to be towed 100 miles to a repair facility in coburg, or, where the found that besides the oil cooler,…”
“While traveling to alaska in our 2005 country coach inspire we had a transmission oil cooler failure which caused the engine coolant to drain into the transmission and causing it to fail. We had to be towed 100 miles to a repair facility in coburg, or, where the found that besides the oil cooler,…”
“Tl*the contact owns a 2005 country coach inspire. The contact did not receive a notice regarding nhtsa campaign id number 07v241000 (exterior lighting). He called the manufacturer and they stated that no recall was available. There had been no failure to date. The current mileage was 23,000.…”
“Tl*- the contact owns a 2005 country coach inspire ,and stated that the windows kept getting foggy. The vehicle hasddual paint windows ,and the deals breakaway allowed the moisture to get inside to fog the windows. It was not possible to clean the windows due to the fact that there was fog between…”
“Tl*the contact owns a 2005 country coach inspire. The contact stated that all the lights on the instrument panel illuminated. The failure has occurred ever since the vehicle was purchased. The dealer initially stated that they would repair the vehicle for free, but have since changed their mind.…”
“Unable to see dashboard display/warning lights in daytime. Have complained since january 2005. All country coach "inspire" models 2005-2006,2007 have same problem. Have been told a fix is being worked on, but to date nothing. *tr”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2005 Country Coach Inspire as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.