RecallRepo

1991 Chrysler Town and Country Recalls

Recalls on record Updated July 2026

The 1991 Chrysler Town and Country has 8 NHTSA recall campaigns affecting an estimated 5,433,240 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 33 complaints with NHTSA, most often about the service brakes, hydraulic. Last updated July 5, 2026.

Recall campaigns

STRUCTURE 99V213000 1999-09-02 1,318,189 affected
Defect

VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN…

Consequence

PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.

Remedy

DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.

VISIBILITY 99V189000 1999-07-16 828,559 affected
Defect

VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.

Consequence

THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.

SEAT BELTS 97V148000 1997-09-09 1,100,000 affected
Defect

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.

Consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy

DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.

SEAT BELTS 97V149000 1997-09-09 1,100,000 affected
Defect

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.

Consequence

IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy

DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.

STEERING 96V229000 1996-11-18 675,000 affected
Defect

THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.

Consequence

IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.

Remedy

DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS IN THE CENTER HUB ATTACHMENT AREA. ANY STEERING WHEELS SHOWING CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.

SERVICE BRAKES, HYDRAULIC 96V099000 1996-06-13 321,000 affected
Defect

THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.

Consequence

IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy

DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE…

SERVICE BRAKES, HYDRAULIC 92V030000 1992-03-10 10,492 affected
Defect

THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE PUMP MAY BE POROUS WHICH WILL RESULT IN BRAKE FLUID LEAKAGE.

Consequence

FLUID LEAKAGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.

Remedy

REPLACE THE ABS HIGH PRESSURE PUMP AND HIGH PRESSURE HOSE IF THE LAST SIX DIGITS OF THE BAR CODE LABEL ON THE PUMP ARE BETWEEN 052300 AND 059262.

SERVICE BRAKES, HYDRAULIC 91V191000 1991-11-01 80,000 affected
Defect

THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE HOSE MAY LEAK OR DETACH AT ITS CRIMPED END FITTING RESULTING IN THE DISCHARGE OF HYDRAULIC FLUID.

Consequence

FLUID DISCHARGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.

Remedy

REPLACE THE ABS HIGH PRESSURE HOSE WITH A HOSE OF DIFFERENT DESIGN AND CONSTRUCTION.

Complaints by component

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
9
1crashes
ENGINE AND ENGINE COOLING:ENGINE
2
LATCHES/LOCKS/LINKAGES:HATCHBACK/LIFTGATE:LOCK
2
1crashes1injuries
POWER TRAIN
2
POWER TRAIN:AUTOMATIC TRANSMISSION
2
AIR BAGS
1
ELECTRICAL SYSTEM:WIRING
1
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
1
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
1
FUEL SYSTEM, GASOLINE:STORAGE
1
Total complaints33

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Tl*the contact owns a 1991 chrysler town and country. While driving 65 mph, a pop sound was suddenly heard and the air bag deployed. The vehicle was driven to the contact's residence and then towed to the dealer. The dealer inspected the vehicle and stated that the seat belt shorted out. The…”

AIR BAGS · reported 2008-09-07

“Tl*the contact owns a 1991 chrysler town and country. While driving 30 mph, the abs failed to operate and the vehicle took 20-30 additional feet to stop. The abs light illuminated intermittently. While at the dealer on february 15, 2008, they stated that there was failure with the wiring and the…”

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP · reported 2007-03-20

“Tl*the contact owns a 1991 chrysler town and country. While driving 30 mph, the abs failed to operate and the vehicle took 20-30 additional feet to stop. The abs light illuminated intermittently. While at the dealer on february 15, 2008, they stated that there was failure with the wiring and the…”

ELECTRICAL SYSTEM:WIRING · reported 2007-03-20

“Dt:the contact received nhtsa recall, campaign 96v099000 concerning abs brakes. While pulling out of a parking space the abs activated. The vehicle was stopped without incident. The vehicle was repaired under this recall. However, the brakes failed twice within a week. The vehicle was repaired…”

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP · reported 2005-10-25

“Nhtsa recall 92v030000 concerning brake pump failure. Consumer contacted the manufacturer, and was told that vehicle was recalled, and to proceed to the dealer for repairs. Consumer had the repairs done, and experienced brake failure four times since the pump was replaced. On each occasion the…”

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC · reported 2004-08-10

“When the brakes are applied there is a delay before the vehicle will stop. *ak”

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP · reported 2004-04-12

“The brake pedal became hard when the driver made a sudden stop which resulted in extended stopping distances. The dealership repaired the vehicle but the problem still exist. *nlm”

SERVICE BRAKES, HYDRAULIC · reported 2003-09-16

“Loss of brakes --car is equipped with antilock brakes --third separate incident. *nlm”

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP · reported 2003-06-13

Defect investigations

Investigation EA94005 Opened 1994-01-31 · closed 1995-10-25

LIFTGATE LATCHES

LIFTGATE LATCHES IN THE SUBJECT VEHICLES HAVE FAILED IN LOW AND MODERATE SPEED IMPACTS RESULTING IN OCCUPANT EJECTIONS, INJURIES, AND FATALITIES.THERE ARE TWO FAILURE MODES ASSOCIATED WITH LATCH FAILURE: FORK BOLT-DETENT LEVER BYPASS, AND INERTIAL UNLATCHING.NHTSA ANALYSES OF CHRYSLER AND PEER MINIVANS TOOK THE FORM…

Investigation EA94028 Opened 1994-07-29 · closed 1996-06-24

ABS BRAKING SYSTEM FAILS

There is no summary currently available

Investigation EA95029 Opened 1995-09-26 · closed 1996-11-13

STEERING WHEEL SEPARATION

AFTER AN EXTENSIVE INVESTIGATION AND ANALYSIS, CHRYSLER HAS IDENTIFIED THE DEFECT AS A FATIGUE FAILURE, ORIGINATION IN THE HEAT AFFECTED REGION OF THE PROJECTION WELDS OF THE STEERING WHEEL HUB TO STEERING WHEEL ARMATURE ATTACHMENT.THE HUB IS THE PORTION OF THE STEERING WHEEL ASSEMBLY THAT CONNECTS IT TO THE STEERING…

Investigation EA96027 Opened 1996-10-31 · closed 1997-05-16

ALLEGED REAR LIFTGATE SUPPORT FAILURE

THE RETAINER BOLT OF THE REAR LIFTGATE SUPPORT CYLINDERS MAY SHEAR RESULTING IN SUDDEN COLLAPSE OF THE REAR HATCH DOOR.

Investigation EA97005 Opened 1997-04-10 · closed 1997-12-23

SAFETY BELT ANCHORAGE FAILURES

There is no summary currently available

Investigation PE91093 Opened 1991-06-28 · closed 1991-10-23

ABS CONTROL FAILURE

There is no summary currently available

Investigation PE91094 Opened 1991-07-05 · closed 1991-11-26

BRAKING PERFORMANCE LOSS

ABS SYSTEM LEAKS ARE ALLEGED BY CONSUMERS WHICH RESULT IN COMPLETE BRAKEFAILURE. SEVERRE LEAKING OCCURS WHILE THE VEHICLE SITS FOR SEVERAL HOURSRESULTING IN COMPLETE LOSS OF FLUID. LEAKS ARE APPEARING IN BOTH THE HIGHAND LOW PRESSURE LINES POSSIBLY DUE TO A FAULTY SEAL OR COUPLING. ONECOMPLAINT ALLEGES FLUID BEING…

Investigation PE91094 Opened 1991-07-05 · closed 1991-11-26

BRAKING PERFORMANCE LOSS

ABS SYSTEM LEAKS ARE ALLEGED BY CONSUMERS WHICH RESULT IN COMPLETE BRAKEFAILURE. SEVERRE LEAKING OCCURS WHILE THE VEHICLE SITS FOR SEVERAL HOURSRESULTING IN COMPLETE LOSS OF FLUID. LEAKS ARE APPEARING IN BOTH THE HIGHAND LOW PRESSURE LINES POSSIBLY DUE TO A FAULTY SEAL OR COUPLING. ONECOMPLAINT ALLEGES FLUID BEING…

Investigation PE93056 Opened 1993-06-09 · closed 1993-09-14

MELTED THROTTLE CABLES

There is no summary currently available

Investigation PE94024 Opened 1994-03-07 · closed 1994-07-29

ABS BRAKING SYSTEM FAILS

There is no summary currently available

Investigation PE96008 Opened 1996-01-25 · closed 1996-06-28

SAFETY BLT LATCH OPERATION

There is no summary currently available

Investigation PE96035 Opened 1996-05-06 · closed 1996-10-31

ALLEGED REAR LIFTGATE SUPPORT FAILURE

THE RETAINER BOLT OF THE REAR LIFT GATE SUPPORT CYLINDERS MAY SHEER RESULTING IN THE SUDDEN COLLAPSE OF THE REAR HATCH DOOR.

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1991 Chrysler Town and Country as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.