The 2023 Chevrolet Tahoe has 5 NHTSA recall campaigns affecting an estimated 1,787,551 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 292 complaints with NHTSA, most often about the engine. Last updated July 20, 2026.
Recall campaigns
FUEL SYSTEM, DIESEL25V6190002025-09-1812 affected
Defect
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
Consequence
A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Remedy
Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number…
ENGINE AND ENGINE COOLING25V2740002025-04-24597,571 affected
Defect
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can…
Consequence
Engine failure increases the risk of a crash.
Remedy
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed…
SERVICE BRAKES, HYDRAULIC24V6740002024-09-12449,671 affected
Defect
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As…
Consequence
Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
Remedy
The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac…
SUSPENSION23V6420002023-09-20189 affected
Defect
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Consequence
A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Remedy
Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this…
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights…
Consequence
DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Remedy
The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at…
Complaints by component
ENGINE
106
1injuries
POWER TRAIN
37
ELECTRICAL SYSTEM
36
2crashes1injuries
SERVICE BRAKES
20
1crashes
ENGINE AND ENGINE COOLING
16
UNKNOWN OR OTHER
14
FUEL/PROPULSION SYSTEM
8
FORWARD COLLISION AVOIDANCE: WARNINGS
7
1crashes
VISIBILITY/WIPER
7
AIR BAGS
6
1crashes
Total complaints292
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“I was a victim to the l87 engine loss of propulsion recall. On june 19, 2025, my engine was replaced as it failed all test. After getting a new engine, I have had 5 engine misfires and the dealership blamed it on faulty gas. Now my 2023 chevrolet tahoe that I trust to drive my two toddlers around,…”
“I was a victim to the l87 engine loss of propulsion recall. On june 19, 2025, my engine was replaced as it failed all test. After getting a new engine, I have had 5 engine misfires and the dealership blamed it on faulty gas. Now my 2023 chevrolet tahoe that I trust to drive my two toddlers around,…”
“Piston ring went bad causing catastrophic engine failure. Now needs new motor. Only had 62k miles. It had been burning oil but was taken to the dealership for maintenance and they didn’t report anything.”
“The contact owns a 2023 chevrolet tahoe. The contact stated that while driving at 40 mph, a warning message advising to reduce acceleration was displayed, the check engine warning light illuminated, and the vehicle stalled. The contact was able to pull over safely. The contact stated that the…”
“The contact owns a 2023 chevrolet tahoe. The contact stated that while driving at 40 mph, a warning message advising to reduce acceleration was displayed, the check engine warning light illuminated, and the vehicle stalled. The contact was able to pull over safely. The contact stated that the…”
“The contact owns a 2023 chevrolet tahoe. The contact stated that while driving at 40 mph, a warning message advising to reduce acceleration was displayed, the check engine warning light illuminated, and the vehicle stalled. The contact was able to pull over safely. The contact stated that the…”
“We had car checked due to strange and erratic shifting in less than a year of owning. Then took in for recall, they stated it was fine and performed the remedy with higher grade oil. Still had issues and took to another dealership to look at and they stated it was fine as well. About 2 months…”
“We had car checked due to strange and erratic shifting in less than a year of owning. Then took in for recall, they stated it was fine and performed the remedy with higher grade oil. Still had issues and took to another dealership to look at and they stated it was fine as well. About 2 months…”
Defect investigations
InvestigationEA25007 Opened 2025-10-23 · open
Loss of motive power due to engine failure
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado…
InvestigationEA25007 Opened 2025-10-23 · open
Loss of motive power due to engine failure
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado…
InvestigationPE25001 Opened 2025-01-16 · closed 2025-10-23
Loss of motive power due to engine failure
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing…
InvestigationPE25001 Opened 2025-01-16 · closed 2025-10-23
Loss of motive power due to engine failure
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing…
InvestigationRQ26001 Opened 2026-01-16 · open
Loss of motive power due to engine failure post recall remedy
The Office of Defects Investigation (ODI) has received 36 Vehicle Owner Questionnaires (VOQs) alleging engine failure in vehicles subject to Recall 25V274. In each VOQ, the engine had the recall remedy completed prior to the reported failure incident. Recall 25V-274 addresses vehicles equipped with a L87 6.2L V8 gas…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2023 Chevrolet Tahoe as of
July 20, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.