RecallRepo

2024 Chevrolet Suburban Recalls

Recalls on record Updated July 2026

The 2024 Chevrolet Suburban has 1 NHTSA recall campaign affecting an estimated 597,571 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 50 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.

Recall campaigns

ENGINE AND ENGINE COOLING 25V274000 2025-04-24 597,571 affected
Defect

General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can…

Consequence

Engine failure increases the risk of a crash.

Remedy

Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed…

Complaints by component

ENGINE
17
1fires
ENGINE AND ENGINE COOLING
6
POWER TRAIN
6
SERVICE BRAKES
5
ELECTRICAL SYSTEM
3
UNKNOWN OR OTHER
2
AIR BAGS
1
BACK OVER PREVENTION: WARNINGS
1
CHILD SEAT
1
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
1
Total complaints50

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“1. Sunroof 2. Driving on 81 n slightly past the middlesex exit at highway speeds. My 4 minor children and I heard what sounded like a large balloon popping inside my car. Upon further inspection, my sunroof spontaneously exploded. Absolutely nothing hit our car. The more research i’m doing, this…”

UNKNOWN OR OTHER · reported 2026-05-08

“Windshield wipers stopped working”

VISIBILITY/WIPER · reported 2026-05-07

“The vehicle would jerk when changing gears and would have a rattle and vibration when accelerating.”

ENGINE · reported 2026-05-02

“The vehicle would jerk when changing gears and would have a rattle and vibration when accelerating.”

POWER TRAIN · reported 2026-05-02

“On may 2, 2026, while the vehicle was in operation, the engine suddenly shut off without warning. At the time of failure, the instrument panel remained illuminated; however, the vehicle would not restart. In an effort to resolve the issue, the battery was replaced, but this did not correct the…”

ENGINE · reported 2026-05-02

“The glass of the front movable sun roof shattered. The glass shattered while driving on hwy 89 in wyoming with no traffic or no identifiable reason for the event. While some glass was saved most of it blew out when is shattered. The problem has not been reproduced or confirmed by the dealer. The…”

UNKNOWN OR OTHER · reported 2026-04-22

“The contact owns a 2024 chevrolet suburban. The contact stated that while driving at approximately 30 mph, the steering wheel locked at an angle, and the message "power steering not active" was displayed, causing the vehicle to strike a curb. The steering column, control arm, radiator, fender, and…”

STEERING · reported 2026-03-23

“Upon stepping on brakes, the car shifts into neutral and says “press start button again.â€� this happened to me 2x now.”

POWER TRAIN · reported 2026-03-06

Defect investigations

Investigation EA25007 Opened 2025-10-23 · open

Loss of motive power due to engine failure

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado…

Investigation EA25007 Opened 2025-10-23 · open

Loss of motive power due to engine failure

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado…

Investigation PE25001 Opened 2025-01-16 · closed 2025-10-23

Loss of motive power due to engine failure

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing…

Investigation PE25001 Opened 2025-01-16 · closed 2025-10-23

Loss of motive power due to engine failure

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing…

Investigation RQ26001 Opened 2026-01-16 · open

Loss of motive power due to engine failure post recall remedy

The Office of Defects Investigation (ODI) has received 36 Vehicle Owner Questionnaires (VOQs) alleging engine failure in vehicles subject to Recall 25V274. In each VOQ, the engine had the recall remedy completed prior to the reported failure incident. Recall 25V-274 addresses vehicles equipped with a L87 6.2L V8 gas…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2024 Chevrolet Suburban as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.