The 2025 Chevrolet Suburban 1500 has 1 NHTSA recall campaign affecting an estimated 2,457 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 36 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.
Recall campaigns
WHEELS26V3040002026-05-142,457 affected
Defect
General Motors, LLC is recalling certain 2025–2026 Cadillac Escalade, Escalade ESV, Chevrolet Suburban 1500, Tahoe, GMC Yukon, and Yukon XL vehicles with 24-inch wheels. Incorrect bolts may have been installed on the left and right front wheel hubs, which can result in the bolts loosening or deforming over time.
Consequence
A bolt that loosens or breaks during vehicle operation can result in loss of vehicle control, increasing the risk of a crash.
Remedy
Dealers will replace the front left and right wheel hub bolts, free of charge. Owner notification letters were mailed June 18, 2026. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-333-4223. GM's number for this recall is…
Complaints by component
ENGINE
13
ELECTRICAL SYSTEM
5
POWER TRAIN
5
UNKNOWN OR OTHER
3
EXTERIOR LIGHTING
2
VEHICLE SPEED CONTROL
2
VISIBILITY/WIPER
2
ENGINE AND ENGINE COOLING
1
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
1
FORWARD COLLISION AVOIDANCE: WARNINGS
1
Total complaints36
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“3.0 duramax, thrust bearing engine failure. Less than 6000 miles on vehicle. Driving at 60 mph when vehicle went into major limp mode. Had tcm, charging and coolant lights illuminate. Gm is replacing engine under warranty. Indicated there was approximately a 2 week engine production window where…”
“3.0 duramax engine failure at 5900 miles. Apparently is from the known thrust bearing issue. Mil, cel, tcm illuminated. Failure occurred at 60 mph during rush hour traffic. Engine is being replaced under warranty. Gm should issue recall for the affected lot of this engine.”
“2025 chevrolet suburban high country. Vehicle is parked in my garage. Went out in the am and the engine only cranks, will not start. Called on star for roadside assistance. Sent a tow truck, the vehicle could not be towed due to the electronic transmission. There is no way for an owner to place…”
“2025 chevrolet suburban high country. Vehicle is parked in my garage. Went out in the am and the engine only cranks, will not start. Called on star for roadside assistance. Sent a tow truck, the vehicle could not be towed due to the electronic transmission. There is no way for an owner to place…”
“Car was parked (in covered area) when back window shattered sometime after 12pm. Car had not been driven in two days and outdoor temperature started at 62 that morning so there were not extreme temperature changes as at the time the window shattered, it was approximately 75 degrees. No apparent…”
“Driving on highway at approx 70mph, lost propulsion and speedometer went to 0. Came back after approx. 5 seconds. After exiting highway and stopping, clear knocking/clanging noise from engine. Gm states full engine replacement needed. This is a 2025 6.2 v8, thought these issues were fixed?”
“We have 8,625 miles on our 2025 suburban. We were going down the highway when began to hear a unfamiliar noise. We pulled over into an error to inspect and didn't notice anything under the vehicle, which we thought might have cause the noise. We put into drive and went less than an 1/8 of a mile…”
“The engine failed right in the middle of a intersection completely shut down, locked up the motor”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2025 Chevrolet Suburban 1500 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.