The 1999 Chevrolet Lumina has 2 NHTSA recall campaigns affecting an estimated 2,501,072 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 132 complaints with NHTSA, most often about the engine and engine cooling. Last updated July 5, 2026.
Recall campaigns
ENGINE AND ENGINE COOLING15V7010002015-10-261,003,556 affected
Defect
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and…
Consequence
Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy
The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engineÂ’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will…
ENGINE AND ENGINE COOLING09V1160002009-04-081,497,516 affected
Defect
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL…
Consequence
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy
DEALERS WILL REPLACE THE ENGINEÂ’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINEÂ’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438,…
Complaints by component
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
11
ENGINE AND ENGINE COOLING
9
1fires
ENGINE AND ENGINE COOLING:COOLING SYSTEM
9
ENGINE AND ENGINE COOLING:ENGINE
7
1fires
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
7
1crashes
ELECTRICAL SYSTEM
6
1fires
AIR BAGS:FRONTAL
4
2crashes4injuries
ENGINE
4
POWER TRAIN:AUTOMATIC TRANSMISSION
4
STEERING
4
Total complaints132
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“I was driving the car home and it shut off , now it won't turn back on”
“1999 chevrolet lumina ls. Consumer writes in regards to vehicle shutting off while driving. *ld the consumer stated the pass-key 11 security system activated while driving causing the vehicle to lose steering and braking functions while being driven. *js”
“My steering wheel has been locking up while driving and I have almost crashed into other vehicles and buildings.”
“I took my car for a service repair. (tune up) only to discover on the waya awkward smell and misfire. Upon arriving I was notified that the internal hood insulation broke free and crumbled in chunks on top of my fuel injector and created a heat that melted four of the fuel injector wires covers…”
“Driving at 70mph there was a there was a large increase in noise and vibration for a minute followed by a loud bang. Inspection revealed that an explosive tire failure had occurred. Several places on the sidewall were torn and the tread had bulges on it. The defective tire was replaced. 2 months…”
“Tl* the contact owns a 1999 chevrolet lumina. The contact stated that oil was leaking on the exhaust manifold and a burning odor was present. The contact received notification of nhsta campaign number: 15v701000 (engine and engine cooling); however, the part to do the repair was unavailable. The…”
“Tl* the contact owns a 1999 chevrolet lumina. The contact stated that the vehicle was leaking oil. The vehicle was taken to the dealer where it was diagnosed that the valve cover gasket failed and needed to be replaced. The vehicle was not repaired. The vin was not included in nhtsa campaign…”
“Tl* the contact owns a 1999 chevrolet lumina. The contact stated that the vehicle was no longer operable. The vehicle was inspected by a technician where it was diagnosed that the failure was due to the head gaskets leaking water into the pistons. The head gaskets needed to be replaced. The…”
Defect investigations
InvestigationEA02030 Opened 2002-10-22 · closed 2004-03-09
ENGINE COMPARTMENT FIRES
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME…
InvestigationEA02030 Opened 2002-10-22 · closed 2004-03-09
ENGINE COMPARTMENT FIRES
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME…
InvestigationEA02030 Opened 2002-10-22 · closed 2004-03-09
ENGINE COMPARTMENT FIRES
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1999 Chevrolet Lumina as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.