1996 Chevrolet Express 1500 Recalls
No NHTSA recalls on record for the 1996 Chevrolet Express 1500. That means NHTSA has no open safety campaign for this vehicle — it does not guarantee the absence of problems. Owners have filed 4 complaints with NHTSA, most often about the service brakes. Last updated July 5, 2026.
Complaints by component
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.
“I was braking while exiting the freeway and lost the rear brakes. After an inspection, I found the brake line broke about midway through the chasse. I also found that the brake lines would crack where ever you bent them. I had to have all the brake system replaced because of corrosion at a cost of…”
“Wife complained of pulsating brake pedal, took vehicle for a short test drive, on the way back while traveling in a straight line at approx. 30 mph made a stop applying moderate pedal pressure, brake pedal went to floor. Carefully drove the remaining 1/8th mile home and crawled underneath van.…”
“Transmission slips and I researched the internet and the 4l60e transmission has a problem where a weld inside the transmission goes bad and makes the transmission fail. Van was taken to a repair shop and rebuilt a few times the mechanic says a new gm transmission must be purchased at $1,600…”
“96 chevy express van, failed side cargo door hinges. These hinges, pins and bushings, fail, seize up, and the side cargo doors are unable to be opened. This makes it unsafe for exit from the vehicle for any persons sitting in the back or rear seats. Gm knows of this problem. There are 4 service…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 1996 Chevrolet Express 1500 as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.