The 2010 Chevrolet Cobalt has 5 NHTSA recall campaigns affecting an estimated 6,865,488 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 794 complaints with NHTSA, most often about the steering. Last updated July 5, 2026.
Recall campaigns
AIR BAGS15V5000002015-08-1059,474 affected
Defect
General Motors LLC (GM) is recalling certain model year 2010 Chevrolet Cobalt vehicles manufactured January 4, 2010, to June 23, 2010. The affected vehicles may be equipped with an improperly routed Side-Impact Sensor (SIS) wiring harness in the driver side front door. The misrouted wiring harness could cause an…
Consequence
A disabled driver side roof-rail air bag will not deploy in the event of a crash necessitating deployment of that air bag, increasing the risk of injury to the driver.
Remedy
GM will notify owners, and dealers will inspect the sensor's wiring in the driver's door and make repairs as necessary, free of charge. The recall began on September 8, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15075.
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the…
Consequence
If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the…
Remedy
General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For…
STEERING14V1530002014-03-311,373,177 affected
Defect
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS)…
Consequence
If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model…
AIR BAGS14V0470002014-02-102,190,934 affected
Defect
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10,…
Consequence
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy
GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected…
STEERING10V0730002010-03-031,050,889 affected
Defect
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Consequence
IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy
DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER…
Complaints by component
STEERING
235
17crashes1fires15injuries
ELECTRICAL SYSTEM
113
9crashes2fires4injuries
FUEL/PROPULSION SYSTEM
101
1crashes4fires
AIR BAGS
76
26crashes1fires27injuries
ENGINE
38
1crashes1injuries
POWER TRAIN
29
1crashes1fires6injuries3deaths
UNKNOWN OR OTHER
28
2crashes1injuries1deaths
SERVICE BRAKES
14
4crashes2injuries
SERVICE BRAKES, HYDRAULIC
13
1crashes2injuries
VEHICLE SPEED CONTROL
13
1crashes
Total complaints794
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Problem with steering column rattle”
“Fuel lines leak around fuel tank, causing a fuel smell around the vehicle and a major fire hazard”
“The contact's daughter owns a 2010 chevrolet cobalt. The contact stated that while driving at various speeds, the power steering assist failed to operate as needed. There was no warning light illuminated. Due to the failure, extra effort was needed to steer the vehicle. The vehicle was not…”
“Air bag says it needs serviced gas gadge is all over the place hard to tell how much gas I actually have in my tank.”
“Air bag says it needs serviced gas gadge is all over the place hard to tell how much gas I actually have in my tank.”
“Our daughter observed a significant puddle forming under her vehicle and noticed a strong smell of gasoline. She sent us a video, which clearly showed gasoline leaking from the driver-side rear area of the car. Due to the proximity of the fuel leak to the exhaust pipe, we had the car towed to a…”
“Unknown”
“Internal mechanism of the driver-side door handle broke and the door would not open from the inside. Tne dealership confirmed that the inside door ah glue is broken. The cable retainer snapped apart and the cable cannot stay connected. This might be available for inspection. Driver must exit the…”
Defect investigations
InvestigationPE20011 Opened 2020-07-05 · closed 2023-08-17
Fuel Line Leak
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal…
InvestigationPE20011 Opened 2020-07-05 · closed 2023-08-17
Fuel Line Leak
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal…
InvestigationPE20011 Opened 2020-07-05 · closed 2023-08-17
Fuel Line Leak
On July 5, 2020, the Office of Defects Investigations (ODI) opened PE20-011 to investigate instances of metal fuel lines under the vehicle corroding and leaking fuel in model year (MY) 2008 through 2010 Chevrolet Cobalt and 2008 through 2009 Chevrolet HHR passenger cars manufactured by General Motors (GM). The metal…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2010 Chevrolet Cobalt as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.