The 2002 Chevrolet Astro has 1 NHTSA recall campaign affecting an estimated 77,055 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 97 complaints with NHTSA, most often about the electrical system. Last updated July 6, 2026.
ON CERTAIN MINIVANS, THE MULTIFUNCTION SWITCH MAY DEVELOP AN OPEN CIRCUIT CONDITION IN THE STOP LAMP OR HAZARD LAMP CIRCUIT THAT RESULTS IN THE STOP LAMPS AND HAZARD LAMPS BEING INOPERATIVE.
Consequence
THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD LEAD TO A VEHICLE CRASH.
Remedy
DEALERS WILL REPLACE THE HAZARD WARNING FLASHER SWITCH AND APPLY SPECIAL GREASE TO THE CONTACTS AT THE TIME OF INSTALLATION OF THE MODULE FREE OF CHARGE. THE REPAIR WOULD BE USED IN VEHICLES IN WHICH THE HAZARD SLIDER BUTTON IS STILL MOVABLE. IF A VEHICLE HAS A HAZARD SLIDER BUTTON THAT IS NOT MOVABLE (FROZEN), THE…
Complaints by component
ELECTRICAL SYSTEM
8
1fires
SERVICE BRAKES, HYDRAULIC
8
3crashes3injuries
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
8
1crashes
STEERING
5
1crashes
VEHICLE SPEED CONTROL
4
4deaths
AIR BAGS
3
2crashes1injuries
POWER TRAIN:AUTOMATIC TRANSMISSION
3
SERVICE BRAKES
3
STRUCTURE:BODY:DOOR
3
1crashes
TIRES
3
Total complaints97
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The contact owns a 2002 chevrolet astro. The contact stated that while driving at an undetermined speed, the accelerator throttle cable fractured in the stuck open position, causing the vehicle to accelerate to approximately 100 mph independently. There were no warning lights illuminated. The…”
“The contact owns a 2002 chevrolet astro. The contact stated that while driving at an undetermined speed, the accelerator throttle cable fractured in the stuck open position, causing the vehicle to accelerate to approximately 100 mph independently. There were no warning lights illuminated. The…”
“Goodyear viva 3 tires suffered stone punctures. Tire size 215/75r15. Bought two new ones 10/5/16 and two more new ones 3/7/17. This vehicle is infrequently driven and only occasionally on county maintained gravel roads. Only drove 18300 miles before first stone puncture 9/27/20. Second stone…”
“While vehicle was being driven.the alert warning light for the air bags illuminated. I was afraid to drive the vehicle due too the air bag inflator might rupture or underinflate. In the event of a crash. An underinflated air bag may not properly protect the occupant. This scenario increases the…”
“When raining widshield wipers dont work as directed, they do what they want. They stay on after shutting them off. And door locks lock and unlock repeatedly. Wipers also shut off in the middle of line of sifht intermittently. Never works correctly”
“When raining widshield wipers dont work as directed, they do what they want. They stay on after shutting them off. And door locks lock and unlock repeatedly. Wipers also shut off in the middle of line of sifht intermittently. Never works correctly”
“Tl* the contact owns a 2002 chevrolet astro. The contact stated that on several occasions, the brake lights and hazard lights failed. The contact stated that if the brake pedal was depressed and the hazard light switch was moved around the lights would function as intended. The vehicle was not…”
“I got in my van to drive to a store and the brake pedal went right to the floor. There was brake fluid leaking from near the rear tire. The steel hard brake line running from the abs unit to the rear axle is rusted through and is leaking. This was a sudden event. Also the fuel lines look to be…”
Defect investigations
InvestigationPE04072 Opened 2004-10-19 · closed 2005-03-21
LOSS OF BRAKE LAMP ILLUMINATION
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA…
InvestigationPE04072 Opened 2004-10-19 · closed 2005-03-21
LOSS OF BRAKE LAMP ILLUMINATION
IN ITS LETTER DATED MARCH 9, 2005, GM STATED THAT IT WOULD CONDUCT A SAFETY RECALL TO REMEDY A FAULTY MULTIFUNCTION SWITCH IN CERTAIN MODEL YEAR (MY) 2001 AND 2002 CHEVROLET ASTRO AND GMC SAFARI VEHICLES; SPECIFICALLY, ALL MY 2001 VEHICLES AND EARLY MY 2002 VEHICLES BUILT BETWEEN MARCH AND AUGUST 2001.SEE NHTSA…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2002 Chevrolet Astro as of
July 6, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.