The 2020 BMW Z4 has 6 NHTSA recall campaigns affecting an estimated 511,730 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 8 complaints with NHTSA, most often about the service brakes. Last updated July 5, 2026.
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
Consequence
A short circuit in the starter relay may increase the risk of a fire.
Remedy
Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs)…
ENGINE21V5980002021-08-0250,024 affected
Defect
BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without…
Consequence
Loss of braking assist can increase the risk of a crash.
Remedy
Dealers will update the engine management software, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact BMW customer service at 1-800-525-7417.
BMW of North America, LLC (BMW) is recalling certain 2020-2021 Z4 and 2020-2021 Toyota Supra vehicles. The weld between the fuel tank halves may have been insufficiently welded, causing the weld to fail.
Consequence
The failed weld may allow fuel to leak, increasing the risk of a fire in the presence of an ignition source.
Remedy
BMW will notify owners, and dealers will replace the fuel tank, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
BMW of North America, LLC (BMW) is recalling certain 2019-2020 Z4 sDrive30i, Z4 M40i and 2020 Toyota Supra vehicles. The headlamps are able to be adjusted horizontally. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices and…
Consequence
Should the headlamps be adjusted horizontally, there could be increased glare and reduced visibility for oncoming drivers, or reduced visibility for the vehicle operator, thereby increasing the risk of a crash.
Remedy
BMW will notify owners, and dealers will inspect the headlamp vertical and horizontal adjustment plugs, correcting them as necessary, free of charge. The recall began December 23, 2020. BMW owners may contact BMW customer service at 1-800-525-7417 or Toyota owners may contact Toyota customer service at…
EXTERIOR LIGHTING19V8500002019-11-27245 affected
Defect
BMW of North America, LLC (BMW) is recalling certain 2020 Z4 M40i, Z4 sDrive30i, 330i and 330i xDrive vehicles as well as 2020 Toyota Supra vehicles. The headlight control units may fail causing a loss of one or both of the headlights.
Consequence
Headlight failure can reduce the driver's visibility, increasing the risk of a crash.
Remedy
BMW will notify owners, and dealers will replace the headlight control units, free of charge. The recall is expected to begin January 17, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
BACK OVER PREVENTION19V6840002019-09-27257,473 affected
Defect
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe…
Consequence
The lack of an image in the back-up camera display increases the risk of a crash.
Remedy
BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
Complaints by component
SERVICE BRAKES
2
1crashes
STEERING
2
ELECTRICAL SYSTEM
1
ENGINE
1
1crashes
STRUCTURE:BODY
1
1crashes
SUSPENSION
1
Total complaints8
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Engine starter safety recall came out in september 2025, with no remedy or parts existing for fixing it. 5 months later, and no timeframe is provided for a remedy. This is a major fire risk given the amount of rain now that could corrode the starter and lead to a fire.”
“Don't know what is causing it. There is major squeaking/whining/grinding noise if even a tiny bit of water gets in there and last couple days after that. And when you turn the steering wheel to the left the squeaking/whining gets louder. And when does do this the suspension if you hit even a small…”
“Don't know what is causing it. There is major squeaking/whining/grinding noise if even a tiny bit of water gets in there and last couple days after that. And when you turn the steering wheel to the left the squeaking/whining gets louder. And when does do this the suspension if you hit even a small…”
“Don't know what is causing it. There is major squeaking/whining/grinding noise if even a tiny bit of water gets in there and last couple days after that. And when you turn the steering wheel to the left the squeaking/whining gets louder. And when does do this the suspension if you hit even a small…”
“Was in a drive thru on 9/6/2020 waiting our turn. Approx. 7 cars in front of us. As we are slowly moving up to order, car in idle, foot on brake. As we are moving forward, when we were up to 3 cars, still idling and foot on brake, the car had fully accelerated, brake not holding the car, inching…”
“Was in a drive thru on 9/6/2020 waiting our turn. Approx. 7 cars in front of us. As we are slowly moving up to order, car in idle, foot on brake. As we are moving forward, when we were up to 3 cars, still idling and foot on brake, the car had fully accelerated, brake not holding the car, inching…”
“Was in a drive thru on 9/6/2020 waiting our turn. Approx. 7 cars in front of us. As we are slowly moving up to order, car in idle, foot on brake. As we are moving forward, when we were up to 3 cars, still idling and foot on brake, the car had fully accelerated, brake not holding the car, inching…”
“Bmw's lane departure system actually pulls the car's steering left or right, and could cause the car to collide with another vehicle or run off the road. I experienced this while driving on the freeway in southern california. The lane departure system almost pulled my vehicle into the adjacent lane.”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2020 BMW Z4 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.