RecallRepo

2010 BMW X5 Sav Recalls

Recalls on record Updated July 2026

The 2010 BMW X5 Sav has 5 NHTSA recall campaigns affecting an estimated 1,973,308 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 27 complaints with NHTSA, most often about the engine. Last updated July 5, 2026.

Recall campaigns

ENGINE AND ENGINE COOLING 22V119000 2022-03-02 917,106 affected
Defect

BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series…

Consequence

An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.

Remedy

This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles…

AIR BAGS 16V071000 2016-02-05 840,000 affected
Defect

BMW of North America, LLC (BMW) is recalling certain model year 2008-2013 128i and 135i coupes and convertibles and 1 Series M coupes, 2006-2011 325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi, 335i, 335xi, 335i xDrive Sedans, 2009-2011 335d sedans, 2006-2012 325xiT, 328i and 328xi sports wagons, 2007-2013 328i,…

Consequence

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy

BMW will notify owners, and dealers will replace the driver's frontal air bag module or inflator depending on the vehicle model, free of charge. The recall began March 9, 2018. Owners may contact BMW customer service at 1-800-525-7417.

ENGINE AND ENGINE COOLING 14V176000 2014-04-10 156,137 affected
Defect

BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i…

Consequence

If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.

Remedy

BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty…

SERVICE BRAKES 13V045000 2013-02-07 30,265 affected
Defect

BMW is recalling certain model year 2007-2010 X5 SAV vehicles, manufactured September 12, 2006, through March 18, 2010 and equipped with an 8-cylinder engine. The brake vacuum pump may leak a small amount of lubricating oil into the hose. The contamination could result in a loss of power assist braking.

Consequence

The loss of power assist in braking could increase stopping distance and lead to a vehicle crash.

Remedy

BMW will notify owners, and dealers will replace the brake vacuum line with one that contains a check valve, free of charge. The recall began during March 2013. Owners may call BMW at 1-800-525-7417 or email BMW at [email protected].

ENGINE AND ENGINE COOLING 12V550000 2012-11-27 29,800 affected
Defect

BMW is recalling certain model year 2009-2012 X5 xDrive 35d SAV diesel vehicles manufactured September 1, 2008, through November 15, 2012. The engine belt idler pulley bolt could loosen and break over time.

Consequence

If the engine belt idler pulley bolt breaks, the vehicle may unexpectedly lose power-assisted steering, increasing the risk of a crash.

Remedy

BMW will notify owners, and dealers will replace and tighten the idler pulley bolt. The recall began on January 15, 2013. Owners may call BMW at 1-800-525-7417 or email BMW at [email protected].

Complaints by component

ENGINE
8
AIR BAGS
4
FUEL/PROPULSION SYSTEM
4
ELECTRICAL SYSTEM
3
1fires
STEERING
3
POWER TRAIN
2
FUEL SYSTEM, DIESEL
1
FUEL SYSTEM, GASOLINE
1
SEATS
1
Total complaints27

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Lost power steering as car was driving approx 50 mph on garden state parkway at top of bridge over the raritan river. Battery warning came on dash, car lost power and then stopped. No collision or injury. Car was towed and repaired by c&t towing and auto repair, rahway nj. Damage observed was…”

ELECTRICAL SYSTEM · reported 2018-06-30

“Lost power steering as car was driving approx 50 mph on garden state parkway at top of bridge over the raritan river. Battery warning came on dash, car lost power and then stopped. No collision or injury. Car was towed and repaired by c&t towing and auto repair, rahway nj. Damage observed was…”

ENGINE · reported 2018-06-30

“Lost power steering as car was driving approx 50 mph on garden state parkway at top of bridge over the raritan river. Battery warning came on dash, car lost power and then stopped. No collision or injury. Car was towed and repaired by c&t towing and auto repair, rahway nj. Damage observed was…”

STEERING · reported 2018-06-30

“This vehicle has had an open recall 18v-336 since may of 2018 . The vehicle manufacturer has yet to provide a remedy to correct this dangerous defect in the vehicle. When will a remedy be provided? It seem almost a year would be enough time to fix this defect .”

FUEL/PROPULSION SYSTEM · reported 2018-05-01

“Repairing the twin-turbo in my car again in less than a year. Last year the hoses were all replaced this year the dealer says one of the two turbo units in the vehicle needs to be replaced (smaller one). The car is doing the same thing it did last year losing power and making it dangerous to drive…”

ENGINE · reported 2017-12-05

“Repairing the twin-turbo in my car again in less than a year. Last year the hoses were all replaced this year the dealer says one of the two turbo units in the vehicle needs to be replaced (smaller one). The car is doing the same thing it did last year losing power and making it dangerous to drive…”

FUEL/PROPULSION SYSTEM · reported 2017-12-05

“A known defect of an engine compartment partition/seal caused outside water to enter the engine compartment. The water drips and accumulates over the last fuel injectors, leading to an eventual short. When the short occurs, the vehicle looses all power. The engine shuts off preventing…”

FUEL SYSTEM, DIESEL · reported 2016-12-12

“A known defect of an engine compartment partition/seal caused outside water to enter the engine compartment. The water drips and accumulates over the last fuel injectors, leading to an eventual short. When the short occurs, the vehicle looses all power. The engine shuts off preventing…”

ENGINE · reported 2016-12-12

Defect investigations

Investigation EA21002 Opened 2021-09-17 · open

Desiccated Air Bag Inflator Rupture

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant…

Investigation EA21002 Opened 2021-09-17 · open

Desiccated Air Bag Inflator Rupture

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant…

Investigation RQ18001 Opened 2018-04-18 · closed 2018-12-01

Idler Pulley Bolt Failure

In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects…

Investigation RQ18001 Opened 2018-04-18 · closed 2018-12-01

Idler Pulley Bolt Failure

In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects…

Investigation RQ18001 Opened 2018-04-18 · closed 2018-12-01

Idler Pulley Bolt Failure

In a May 23, 2018 letter, BMW of North America, LLC (BMW) notified the National Highway Traffic Safety Administration (NHTSA) of a safety defect that may result in the loss of power steering assist in certain model year (MY) 2009 through 2013 BMW X5 xDrive35d vehicles (Recall 18V-336). The recall, which affects…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2010 BMW X5 Sav as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.