2012 BMW 535xi Recalls
No NHTSA recalls on record for the 2012 BMW 535xi. That means NHTSA has no open safety campaign for this vehicle — it does not guarantee the absence of problems. Owners have filed 23 complaints with NHTSA, most often about the tires. Last updated July 5, 2026.
Complaints by component
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.
“Water condenses inside the front headlights impacting the performance of the lighting ssystem. Reported this when the car was new but was told it was normal. Since then I have found many others reporting the same problem”
“My car has 76,000 miles on it and the error popped up on the main screen of " "passenger restraint system malfunction." it advised me to take the car to a service center which I did. Bmw of wichita diagnosed the issue as the passenger seat mat needed to be replaced. They quoted me $2,500 to fix…”
“My car has 76,000 miles on it and the error popped up on the main screen of " "passenger restraint system malfunction." it advised me to take the car to a service center which I did. Bmw of wichita diagnosed the issue as the passenger seat mat needed to be replaced. They quoted me $2,500 to fix…”
“My car has 76,000 miles on it and the error popped up on the main screen of " "passenger restraint system malfunction." it advised me to take the car to a service center which I did. Bmw of wichita diagnosed the issue as the passenger seat mat needed to be replaced. They quoted me $2,500 to fix…”
“The passenger side seat heater suddenly began to overheat when the car was approximately 3 years old. The heat became so intense it was necessary to turn off the heater for fear of burns. The seat was replaced under warranty. The problem just recurred with the new seat, three years after the first…”
“Front headlights builds up condensation and alot of water. Lowering visibility.”
“Car has had 3 blow outs of run flat goodyear ls2 tires on highway and 3 tires with sidewall bubbles that were unsafe to drive vehicle. 5 tires have been replaced in less than 10 months and less than 5,000 mile on a tire. The vehicle has 35,000 miles in 37 months of ownership.”
“Bmw has an issue with run flat tire on certain models and continues to replace these tires, knowing that there is a safety issue with goodyear eagle ls2 tires. Having recently replaced 5 tires recently and a 6th tire two years ago the problem continues. Bmw corporate customer service claims these…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2012 BMW 535xi as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.