The 2015 BMW 528i has 1 NHTSA recall campaign affecting an estimated 720,796 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 105 complaints with NHTSA, most often about the electrical system. Last updated July 6, 2026.
BMW of North America, LLC. (BMW) is recalling certain 2012-2015 X1 sDrive28i, X1 xDrive28i, 2012-2016 Z4 sDrive28i, 528i, 528i xDrive, 328i, 328xi, 2016-2018 X5 xdrive 40e, 2014-2016 228i, 228xi, 428i, 428i xDrive, 328xi Gran Turismo, 2013-2017 X3 sDrive28i, X3 xDrive28i, 2015-2018 X4 xDrive28i, 2015-2016 428xi…
Consequence
An electrical short increases the risk of a fire.
Remedy
Dealers will inspect and replace the water pump and plug connector as necessary, and install a protective shield, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact BMW customer service at 1-800-525-7417.
Complaints by component
ELECTRICAL SYSTEM
35
2fires
ENGINE AND ENGINE COOLING
32
1fires
ENGINE
13
2fires
UNKNOWN OR OTHER
7
STRUCTURE:BODY
5
2fires
FUEL/PROPULSION SYSTEM
2
POWER TRAIN
2
VISIBILITY:SUN/MOON ROOF ASSEMBLY
2
AIR BAGS
1
1injuries
EXTERIOR LIGHTING
1
Total complaints105
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“The vehicle was driven for approximately 30 minutes, operating with zero dashboard warnings or performance indicators. The vehicle was then parked on my property and turned off completely. Approximately two hours and thirty minutes later, the vehicle spontaneously ignited while stationary and…”
“The vehicle was driven for approximately 30 minutes, operating with zero dashboard warnings or performance indicators. The vehicle was then parked on my property and turned off completely. Approximately two hours and thirty minutes later, the vehicle spontaneously ignited while stationary and…”
“The vehicle was driven for approximately 30 minutes, operating with zero dashboard warnings or performance indicators. The vehicle was then parked on my property and turned off completely. Approximately two hours and thirty minutes later, the vehicle spontaneously ignited while stationary and…”
“The contact owns a 2015 bmw 528i. The contact stated that there was water accumulated inside the passenger’s side headlight assembly, causing the daytime running light to become inoperable. The vehicle was taken to an independent mechanic, who determined that the headlight assembly and module…”
“Upon triggering the trunk release, the integrated hydraulic dampeners failed to mitigate the tension of the lift springs. The trunk lid swung open with enough velocity to over-extend the hinges and strike the rear windshield, causing the tempered glass to shatter.”
“On the morning of november 2, 2025, around 10:30, I had drove up to the church, parked my car. What I thought was an overheated engine. I decided to go inside the church and deal with what I thought was an overheated engine. About 12-25 minutes later, while inside the church, I got new that a…”
“Engine light stays on. Had it looked at by mechanic. Told the issue is the valtronic actuator. Car cuts off when idling. Starts back up and drives, when I come to a stop light/stop sign car cuts off again. Have contacted bmw north america and a dealership, keep getting the runaround. Refer me back…”
“Engine light stays on. Had it looked at by mechanic. Told the issue is the valtronic actuator. Car cuts off when idling. Starts back up and drives, when I come to a stop light/stop sign car cuts off again. Have contacted bmw north america and a dealership, keep getting the runaround. Refer me back…”
Defect investigations
InvestigationEA21002 Opened 2021-09-17 · open
Desiccated Air Bag Inflator Rupture
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant…
InvestigationEA21002 Opened 2021-09-17 · open
Desiccated Air Bag Inflator Rupture
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant…
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2015 BMW 528i as of
July 6, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.