RecallRepo

2006 BMW 5 Series Recalls

Recalls on record Updated July 2026

The 2006 BMW 5 Series has 7 NHTSA recall campaigns affecting an estimated 1,695,060 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 125 complaints with NHTSA, most often about the air bags. Last updated July 5, 2026.

Recall campaigns

ENGINE AND ENGINE COOLING 22V119000 2022-03-02 917,106 affected
Defect

BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series…

Consequence

An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.

Remedy

This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles…

ELECTRICAL SYSTEM 12V126000 2012-03-26 367,682 affected
Defect

BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, MODEL YEAR 2004-2010 6-SERIES, MODEL YEAR 2006-2010 M5, AND MODEL YEAR 2007-2010 M6 VEHICLES. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT…

Consequence

OVERHEATING COULD LEAD TO A FIRE, EVEN WHILE THE VEHICLE IS NOT IN USE. AS A PRECAUTION, OWNERS ARE ADVISED TO PARK OUTSIDE UNTIL THE REMEDY HAS BEEN MADE.

Remedy

BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.

SERVICE BRAKES, HYDRAULIC 10V446000 2010-10-01 198,352 affected
Defect

BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.

Consequence

POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.

Remedy

BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

AIR BAGS 08V384000 2008-08-05 200,000 affected
Defect

BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE…

Consequence

IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.

Remedy

DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW…

SUSPENSION 06V277000 2006-07-26 11,640 affected
Defect

ON CERTAIN PASSENGER VEHICLES, THE LOWER RUBBER MOUNT OF THE REAR SHOCK ABSORBERS MAY NOT HAVE BEEN MANUFACTURED TO SPECIFICATIONS AND MAY NOT ADHERE CORRECTLY TO ITS HOUSING WITHIN THE SHOCK ABSORBER.

Consequence

THE BUSHING COULD LOOSEN AND OVER TIME COULD SEPARATE FROM ITS HOUSING. THE DRIVER WILL EXPERIENCE IMPAIRED VEHICLE HANDLING AND CONTROL INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL REPLACE THE REAR SHOCK ABSORBER FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 13, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

SUSPENSION 06V187000 2006-05-30 40 affected
Defect

ON CERTAIN PASSENGER VEHICLES, THE NUTS WHICH SECURE THE FRONT AXLE CONTROL ARM AND TENSION STRUT TO THE FRONT WHEEL HUB MAY NOT HAVE BEEN TIGHTENED TO SPECIFICATION. OVER TIME THE NUTS COULD LOOSEN AND THE CONTROL ARM AND TENSION STRUT COULD BE DAMAGED.

Consequence

VEHICLE HANDLING AND CONTROL COULD COMPROMISE INCREASING THE RISK OF A CRASH.

Remedy

DEALERS WILL RETIGHTEN THE FRONT AXLE CONTROL ARM AND TENSION STRUT NUTS TO THE CORRECT SPECIFICATIONS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 28, 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

POWER TRAIN 05V504000 2005-11-01 240 affected
Defect

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECTLY MANUFACTURED AUTOMATIC TRANSMISSION PARKING PAWL GUIDE PLATE.

Consequence

THIS COULD CAUSE THE PARKING LOCK SYSTEM NOT TO ENGAGE, AFTER THE TRANSMISSION IS PLACED IN THE PARK ("P") POSITION. IF THE VEHICLE WAS PARKED ON AN INCLINE, AND THE PARKING BRAKE WAS NOT ENGAGED, THIS COULD RESULT IN A VEHICLE ROLLAWAY CONDITION.

Remedy

DEALERS WILL REPAIR AND REPLACE THE AUTOMATIC TRANSMISSION GUIDE PLATE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT BMW AT 1-800-332-4269.

Complaints by component

AIR BAGS
21
1crashes1fires1injuries
ELECTRICAL SYSTEM
18
1crashes1fires2injuries
AIR BAGS:FRONTAL
13
2crashes1injuries
ENGINE
6
POWER TRAIN:AUTOMATIC TRANSMISSION
6
EXTERIOR LIGHTING
4
VISIBILITY
4
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
3
LATCHES/LOCKS/LINKAGES
3
1crashes1injuries
SEATS
3
Total complaints125

What owners report

Verbatim reports filed with NHTSA, lightly edited for readability and with personal information removed.

“Tl* the contact owns a 2006 bmw 5 series. The contact stated that the vehicle leaked oil and the brakes failed while driving at low speeds. The brakes worked normally when applied at high speeds. The vehicle was taken to an independent mechanic who diagnosed that a new power brake booster and…”

SERVICE BRAKES · reported 2019-05-22

“Tl* the contact owns a 2006 bmw 5 series. The contact stated that the vehicle leaked oil and the brakes failed while driving at low speeds. The brakes worked normally when applied at high speeds. The vehicle was taken to an independent mechanic who diagnosed that a new power brake booster and…”

ENGINE · reported 2019-05-22

“Front passenger seat occupancy detection mat had to be replaced as it was defective. Though not in previous recalls in similar bmws and similar years, the error presented a safety issue that would disable the front passenger air bags and increase the risk of injury during a crash. With this error,…”

AIR BAGS · reported 2017-06-21

“Head lights angle lights wires getting very dry from the heat of the light and the insulation coming off the optical wires, lights go out, possible shorting and become very unsafe.”

ELECTRICAL SYSTEM · reported 2017-04-01

“Head lights angle lights wires getting very dry from the heat of the light and the insulation coming off the optical wires, lights go out, possible shorting and become very unsafe.”

EXTERIOR LIGHTING · reported 2017-04-01

“Navigation display reboots constantly. Works periodically. This display gives me access to all of the cars features including warnings and malfunctions with the vehicle. If the display works when the car is on it may not work if you turn off the card and turn it back on.”

ELECTRICAL SYSTEM · reported 2016-05-02

“Navigation display reboots constantly. Works periodically. This display gives me access to all of the cars features including warnings and malfunctions with the vehicle. If the display works when the car is on it may not work if you turn off the card and turn it back on.”

UNKNOWN OR OTHER · reported 2016-05-02

“My passenger air bag warning light came on about a month ago for apparent reason and stay on ever since. I contacted the local bmw dealer and was told my vin was not on the recall list. I was very disappointed and dont understand why some cars were on the recall and some were not. Apparently this…”

AIR BAGS · reported 2016-01-12

Defect investigations

Investigation EA08001 Opened 2008-01-04 · closed 2008-12-31

BMW AIRBAG LIGHT ILLUMINATION

BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND…

Investigation EA08001 Opened 2008-01-04 · closed 2008-12-31

BMW AIRBAG LIGHT ILLUMINATION

BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND…

Investigation EA08001 Opened 2008-01-04 · closed 2008-12-31

BMW AIRBAG LIGHT ILLUMINATION

BMW IS CONDUCTING A SAFETY RECALL CAMPAIGN ON APPROXIMATELY 200,000 MY04 THROUGH MY06 SUBJECT VEHICLES BUILT THROUGH 11/30/05 TO CORRECT THE FRONT PASSENGER SEAT AIR BAG OCCUPANT DETECTION MAT. THE SPECIFIC VEHICLES INCLUDED IN THE RECALL AREMY04- 06/ 5-SERIES WITH STANDARD AND SPORT SEATS, MY04-06/ X3-SERIES AND…

Investigation PE07045 Opened 2007-09-04 · closed 2008-01-04

BMW AIRBAG LIGHT ILLUMINATION

IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE…

Investigation PE07045 Opened 2007-09-04 · closed 2008-01-04

BMW AIRBAG LIGHT ILLUMINATION

IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE…

Investigation PE07045 Opened 2007-09-04 · closed 2008-01-04

BMW AIRBAG LIGHT ILLUMINATION

IN CERTAIN MY 2005 THROUGH MY 2006 BMW VEHICLES, THE OCCUPANT CLASSIFICATION SYSTEM (OCS) FOR THE PASSENGER FRONTAL AIRBAG MAY MALFUNCTION AND RENDER THE PASSENGER AIRBAG INOPERATIVE.IN JUNE 2006, BMW ISSUED A TECHNICAL SERVICE BULLETIN (SI B 72 02 06) REGARDING THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE…

Sources & methodology

Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL, FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2006 BMW 5 Series as of July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page contains ads and affiliate links. Full methodology.