The 2022 BMW 330i has 3 NHTSA recall campaigns affecting an estimated 87,542 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 6 complaints with NHTSA, most often about the tires. Last updated July 13, 2026.
BMW of North America, LLC (BMW) is recalling certain 2021-2023 Toyota Supra, 2022-2023 2 Series Coupe, 2021-2024 5 Series (xDrive), 2021-2022 Z4, 2022-2024 4 Series (Gran Coupe), 2021-2024 4 Series (Convertible and xDrive Convertible), 2021-2023 4 Series (Coupe), 2021-2024 3 Series, 2021-2023 X4, 2021-2024 X3…
Consequence
Fire increases the risk of injury.
Remedy
Dealers will replace the engine starter, free of charge. A letter informing owners of the safety risk was mailed on March 27, 2026. Owners will receive another letter once the remedy is available. Owners may contact BMW customer service at 1-800-525-7417 or Toyota's customer service at 1-800-331-4331. Vehicle…
ELECTRICAL SYSTEM23V5840002023-08-16144 affected
Defect
BMW of North America, LLC (BMW) is recalling certain 2019-2022 330i, 330i xDrive, M340i, 2022 430i Coupe, 2021-2022 430i, M440i Convertible, and 2020-2022 228i xDrive Gran Coupe vehicles. The receiver audio module control unit software may fail to properly generate audible seat belt warnings to the driver to fasten…
Consequence
An audible chime that does not properly alert the driver to fasten their seat belt increases the risk of injury in a crash.
Remedy
Dealers will update the receiver audio module software, free of charge. Owner notification letters were mailed October 12, 2023. Owners may contact BMW customer service at 1-800-525-7417.
POWER TRAIN22V0700002022-02-094 affected
Defect
BMW of North America, LLC (BMW) is recalling certain 2022 330i, 530i, X3 xDrive30i, and X4 xDrive30i vehicles. The mechatronics unit inside the transmission may not have been assembled properly, which could result in an internal leak.
Consequence
An internal transmission leak can result in a vehicle rollaway, increasing the risk of a crash or injury.
Remedy
Dealers will replace the transmission mechatronics unit, free of charge. All of the vehicle population for this recall have been repaired. Owner notification letters were not mailed. Owners may contact BMW customer service at 1-800-525-7417.
Complaints by component
TIRES
3
ELECTRICAL SYSTEM
1
POWER TRAIN
1
UNKNOWN OR OTHER
1
Total complaints6
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“See attached document for complaint.”
“Sunroof exploded out of nowhere. The glass shattered everywhere.”
“Approached my parked car and noticed a 2.5-inch gash in the sidewall of the tire. No warning light in dashboard. Tire pressure remained at recommended pressure. Previous driving was on 35 mph local roads with optimal driving conditions--clear weather and no road hazards. Drove vehicle to dealer to…”
“Driving on highway at 75 mph, tire "exploded" resulting in immediate loss of air pressure and some lack of steering control. Road conditions were optimal with clear sunny weather and no road hazards. Dashboard warning light appeared upon tire failure. Drove with hazards to dealership who replaced…”
“Driving at 75 mph on highway, tire "exploded". Tire air pressure immediately dropped to zero, resulting in some lack of steering control. Warning message on dash appeared upon tire failure. Drove with caution lights to open gas station. A 4-inch slash was visible in the sidewall of the tire. Car…”
“Car had 1,645 miles rear left axle broke. Car would not move. Had this occurred on a highway I easily could have been rear ended. Part must have been defective, dealer replaced the part left rear cv joint but not the right, nor did the dealer confirm both rear axles were not from the same batch.…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2022 BMW 330i as of
July 13, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.