The 2011 Audi Q5 has 5 NHTSA recall campaigns affecting an estimated 1,205,533 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 192 complaints with NHTSA, most often about the air bags. Last updated July 5, 2026.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2007-2012 Audi Q7 and 2009-2012 Audi Q5 vehicles, previously repaired under NHTSA recall 16V-660. These vehicles were previously repaired with an interim repair of installing butyl tape to the fuel pump flange, until replacement remedy parts became…
Consequence
The butyl tape may not prevent fuel from leaking. A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy
Volkswagen will notify owners, and dealers will replace the fuel pump flange and install butyl tape, free of charge. The recall began December 28, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20BJ.
AIR BAGS18V0820002018-01-30162,782 affected
Defect
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2006-2013 Audi A3, 2007-2009 A4 Cabriolet and S4 Cabriolet, 2008 RS4 Cabriolet, 2009-2012 Q5, and 2010-2012 Audi A5 Cabriolet and S5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the…
Consequence
In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy
Audi will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began February 23, 2018. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 69R6. Note: This recall partially…
AIR BAGS17V0010002017-01-03234,057 affected
Defect
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2011-2017 Audi Q5 vehicles. The sunroof drainage system may allow water to soak into the foam surrounding the side head air bag inflator canister resulting in the corrosion of the canister. If this happens, the corrosion can weaken the canister and…
Consequence
An inflator rupture may result in metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy
Audi will notify owners, and dealers will inspect the inflator and either coat it or replace it, as necessary, after removing the surrounding foam, free of charge. The recall is expected to began March 2017. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 69P1.
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.
Consequence
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may…
AIR BAGS16V0780002016-02-10659,493 affected
Defect
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag,…
Consequence
In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy
Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available.…
Complaints by component
AIR BAGS
67
3crashes2injuries
ENGINE
42
2fires
FUEL/PROPULSION SYSTEM
25
POWER TRAIN
12
1fires
ELECTRICAL SYSTEM
8
1crashes
UNKNOWN OR OTHER
8
FUEL SYSTEM, GASOLINE
7
SERVICE BRAKES
3
1crashes
STEERING
3
STRUCTURE:BODY
3
1crashes1fires
Total complaints192
What owners report
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Rear subframe rust causing car to fail state inspection. This vehicle has been maintained well and always parked in garage. The rear subframe rusted most, then front subframe. This is a common compliant among audi forum users.”
“Rear driver side door will not unlock when keypad, nor inside unlock button is pressed. Once inside, door will not unlock in sequence with other doors when vehicle is shut off and it is time to exit the vehicle.”
“Audi q5 shows no recalls on my vehicle. My car stops randomly while driving even while being on highways and interstates. As well as the passenger side leaking due to sunroof drainage coming to the inside (which may affect the air bags). This car has not had any repairs on recalls that I know of…”
“Audi q5 shows no recalls on my vehicle. My car stops randomly while driving even while being on highways and interstates. As well as the passenger side leaking due to sunroof drainage coming to the inside (which may affect the air bags). This car has not had any repairs on recalls that I know of…”
“Audi q5 shows no recalls on my vehicle. My car stops randomly while driving even while being on highways and interstates. As well as the passenger side leaking due to sunroof drainage coming to the inside (which may affect the air bags). This car has not had any repairs on recalls that I know of…”
“Accident head on collision with wall airbags didn't deploy”
“The contact's wife owns a 2011 audi q5. The contact stated that after he parked the vehicle in his garage, he smelled a fuel odor outside of the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed that the flange had cracked and needed to be…”
“During a routine inspection my mechanic noticed the subframe of my 2011 audi q5 was rusted through in numerous spots. It seemed odd that a vehicle bought new and garaged since it was purchased had such extensive rust. Pictures of the rusted subframe were taken and shown to the local audi dealer.…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2011 Audi Q5 as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.