The 2004 Airstream International Ccd has 2 NHTSA recall campaigns affecting an estimated 4,269 vehicles. Recall repairs are always free at any authorized dealer. Owners have filed 4 complaints with NHTSA, most often about the air bags. Last updated July 5, 2026.
Recall campaigns
SUSPENSION04V5060002004-10-25929 affected
Defect
ON CERTAIN MOTORHOMES, THE OUTER WHEEL BEARING IN THE HUB OF THE AXLE MAY FAIL, LEADING TO UNEXPECTED SEPARATION OF THE WHEEL FROM THE AXLE. THIS FAILURE MAY BE DUE TO AN INADEQUATE AMOUNT OF GREASE IN THE HUB ASSEMBLY OR THE GREASE IN THE HUB MAY BREAK DOWN UNDER NORMAL OPERATING CONDITIONS INTO A LIQUID THAT…
Consequence
SEPARATION OF ONE OR MORE WHEELS FROM THE TRAILER COULD CAUSE THE TRAILER TO HANDLE ERRATICALLY OR GO OUT OF CONTROL. A LOST WHEEL COULD ALSO STRIKE AN ONCOMING OR FOLLOWING VEHICLE CAUSING A CRASH, RESULTING IN SERIOUS INJURY OF DEATH TO THOSE INVOLVED.
Remedy
DEALERS WILL REPAIR THE UNIT AND REMOVE THE WHEELS, INSPECT THE HUBS, INNER AND OUTER BEARINGS, RACES AND GREASE SEALS. IF NECESSARY, REPLACE PARTS AND REPACK THE WHEEL BEARING WITH HIGH TEMPERATURE GREASE AND REINSTALL THE HUB AND WHEELS. THE RECALL BEGAN NOVEMBER 4, 2004. OWNERS SHOULD CONTACT AIRSTREAM AT…
EQUIPMENT03V4640002003-11-123,340 affected
Defect
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Consequence
AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy
SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR…
Verbatim reports filed with NHTSA, lightly edited for readability and with personal
information removed.
“Tl* the contact owns a 2004 airstream international ccd trailer. The contact stated that the out riggers were putting pressure on the frame and causing it to crack. The vehicle was not taken to the dealer to have the failure diagnosed. The manufacturer was made aware of the failure and the contact…”
“H *tr”
“H *tr”
“While pulling a trailer and driving at 55 mph up a hill consumer was informed that he had a flat tire on the trailer. Consumer examined the flat tire, and saw no damage, but did notice that the hub of the wheel was burnt. Consumer felt the burnt spot and it was hot to touch. Dealer examined the…”
Recall, complaint, and investigation records from official NHTSA datasets (FLAT_RCL,
FLAT_CMPL, FLAT_INV), synced weekly. Counts reflect NHTSA records for the 2004 Airstream International Ccd as of
July 5, 2026. Complaint narratives are consumer-submitted and unverified. This page
contains ads and affiliate links. Full methodology.